Culp Inc 10-Q for FY2024 Q2
Culp Inc (CULP)
About this 10-Q
Culp Inc filed this 10-Q on September 6, 2024, covering the quarter ended July 28, 2024 (FY2024 Q2).
Headline figures
Quarter ended July 28, 2024, as reported in this filing, compared with the same period a year earlier where the filing states it.
- Revenue
- $56.54M
- down 0.2% from $56.66M a year earlier
- Net loss
- $7.26M
- compared with a net loss of $3.34M a year earlier
- Diluted EPS
- -$0.58
- compared with -$0.27 a year earlier
UNITED STATES
SECURITIES AND EXCHANGE COMMISSION
Washington, D.C. 20549
FORM
QUARTERLY REPORT PURSUANT TO SECTION 13 OR 15(d)
OF THE SECURITIES EXCHANGE ACT OF 1934
For the quarterly period ended
Commission File No.
(Exact name of registrant as specified in its charter)
(State or other jurisdiction of incorporation or other organization) |
(I.R.S. Employer Identification No.) |
|
|
(Address of principal executive offices) |
(zip code) |
(
(Registrant's telephone number, including area code)
Securities registered pursuant to Section 12(b) of the Act:
|
|
|
|
Name of Each Exchange |
Title of Each Class |
|
Trading Symbol(s) |
|
On Which Registered |
|
|
Indicate by check mark whether the registrant (1) has filed all reports required to be filed by Section 13 or 15(d) of the Securities Exchange Act of 1934 during the preceding 12 months (or for such shorter period that the registrant was required to file such reports) and (2) has been subject to such filing requirements for the past 90 days. ☒
Indicate by check mark whether the registrant has submitted electronically every Interactive Data File required to be submitted pursuant to Rule 405 of Regulation S-T (§ 232.405 of this chapter) during the preceding 12 months (or for such shorter period after the registrant was required to submit such files). ☒
Indicate by check mark whether the registrant is a large accelerated filer, an accelerated filer, a non-accelerated filer, a smaller reporting company, or an emerging growth company. See the definitions of “large accelerated filer,” “accelerated filer,” “smaller reporting company,” and “emerging growth company” in Rule 12b-2 of the Exchange Act.
Large accelerated filer |
|
☐ |
|
Accelerated filer |
|
☐ |
|
|
|
|
|||
|
☒ |
|
Smaller Reporting Company |
|
||
|
|
|
|
|||
|
|
|
|
Emerging Growth Company |
|
|
If an emerging growth company, indicate by check mark if the registrant has elected not to use the extended transition period for complying with any new or revised financial accounting standards provided pursuant to Section 13(a) of the Exchange Act. ☐
Indicate by check mark whether the registrant is a shell company (as defined in Rule 12b-2 of the Exchange Act). ☐ Yes No
Indicate the number of shares outstanding of each of the issuer’s classes of common stock, as of the latest practicable date:
Common shares outstanding as of September 5, 2024:
Par Value: $0.05 per share
INDEX TO FORM 10-Q
For the period ended July 28, 2024
|
|
Part I - Financial Statements |
|
Page |
|
|
|
|
|
Item 1. |
|
|
I-1 |
|
|
|
|
|
|
|
|
Consolidated Statements of Net Loss — Three Months Ended July 28, 2024, and July 30, 2023 |
|
I-1 |
|
|
|
|
|
|
|
Consolidated Statements of Comprehensive Loss – Three Months Ended July 28, 2024 and July 30, 2023 |
|
I-2 |
|
|
|
|
|
|
|
Consolidated Balance Sheets — July 28, 2024, July 30 2023, and April 28, 2024 |
|
I-3 |
|
|
|
|
|
|
|
Consolidated Statements of Cash Flows — Three Months Ended July 28, 2024, and July 30, 2023 |
|
I-4 |
|
|
|
|
|
|
|
Consolidated Statements of Shareholders’ Equity – Three Months Ended July 28, 2024 |
|
I-5 |
|
|
|
|
|
|
|
Consolidated Statements of Shareholders’ Equity – Three Months Ended July 30, 2023 |
|
I-6 |
|
|
|
|
|
|
|
|
I-7 |
|
|
|
|
|
|
|
|
|
I-29 |
|
|
|
|
|
|
Item 2. |
|
Management's Discussion and Analysis of Financial Condition and Results of Operations |
|
I-30 |
|
|
|
|
|
Item 3. |
|
|
I-45 |
|
|
|
|
|
|
Item 4. |
|
|
I-45 |
|
|
|
|
|
|
|
|
Part II - Other Information |
|
|
|
|
|
|
|
Item 1. |
|
|
II-1 |
|
|
|
|
|
|
Item 1A. |
|
|
II-1 |
|
|
|
|
|
|
Item 2. |
|
|
II-1 |
|
|
|
|
|
|
Item 5. |
|
|
II-1 |
|
|
|
|
|
|
Item 6. |
|
|
II-2 |
|
|
|
|
|
|
|
II-3 |
|||
Item 1: Financial Statements
CULP, INC.
CONSOLIDATED STATEMENTS OF NET LOSS
FOR THE THREE MONTHS ENDED JULY 28, 2024, AND JULY 30, 2023
UNAUDITED
(Amounts in Thousands, Except for Per Share Data)
|
|
THREE MONTHS ENDED |
|
|||||
|
|
July 28, |
|
|
July 30, |
|
||
|
|
2024 |
|
|
2023 |
|
||
Net sales |
|
$ |
|
|
$ |
|
||
Cost of sales |
|
|
( |
) |
|
|
( |
) |
Gross profit |
|
|
|
|
|
|
||
Selling, general and administrative expenses |
|
|
( |
) |
|
|
( |
) |
Restructuring expense |
|
|
( |
) |
|
|
( |
) |
Loss from operations |
|
|
( |
) |
|
|
( |
) |
Interest expense |
|
|
( |
) |
|
|
— |
|
Interest income |
|
|
|
|
|
|
||
Other (expense) income |
|
|
( |
) |
|
|
|
|
Loss before income taxes |
|
|
( |
) |
|
|
( |
) |
Income tax expense |
|
|
( |
) |
|
|
( |
) |
Net loss |
|
|
( |
) |
|
$ |
( |
) |
|
|
|
|
|
|
|
||
Net loss per share - basic |
|
$ |
( |
) |
|
$ |
( |
) |
Net loss per share - diluted |
|
$ |
( |
) |
|
$ |
( |
) |
Average shares outstanding, basic |
|
|
|
|
|
|
||
Average shares outstanding, diluted |
|
|
|
|
|
|
||
See accompanying notes to consolidated financial statements.
I-1
CULP, INC.
CONSOLIDATED STATEMENTS OF COMPREHENSIVE LOSS
FOR THE THREE MONTHS ENDED JULY 28, 2024, AND JULY 30, 2023
UNAUDITED
(Amounts in Thousands)
|
|
THREE MONTHS ENDED |
|
|||||
|
|
July 28, |
|
|
July 30, |
|
||
|
|
2024 |
|
|
2023 |
|
||
Net loss |
|
$ |
( |
) |
|
$ |
( |
) |
Unrealized holding gain on investments, net of tax |
|
|
|
|
|
|
||
Comprehensive loss |
|
$ |
( |
) |
|
$ |
( |
) |
See accompanying notes to consolidated financial statements.
I-2
CULP, INC.
CONSOLIDATED BALANCE SHEETS
JULY 28, 2024, JULY 30, 2023, AND APRIL 28, 2024
UNAUDITED
(Amounts in Thousands)
|
|
July 28, |
|
|
July 30, |
|
|
April 28, |
|
|||
|
|
2024 |
|
|
2023 |
|
|
2024* |
|
|||
Current assets: |
|
|
|
|
|
|
|
|
|
|||
Cash and cash equivalents |
|
$ |
|
|
$ |
|
|
$ |
|
|||
Short-term investments - rabbi trust |
|
|
|
|
|
|
|
|
|
|||
Accounts receivable, net |
|
|
|
|
|
|
|
|
|
|||
Inventories |
|
|
|
|
|
|
|
|
|
|||
Short-term note receivable |
|
|
|
|
|
|
|
|
|
|||
Assets held for sale |
|
|
|
|
|
— |
|
|
|
— |
|
|
Current income taxes receivable |
|
|
|
|
|
|
|
|
|
|||
Other current assets |
|
|
|
|
|
|
|
|
|
|||
Total current assets |
|
|
|
|
|
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
|
|||
Property, plant and equipment, net |
|
|
|
|
|
|
|
|
|
|||
Right of use assets |
|
|
|
|
|
|
|
|
|
|||
Intangible assets |
|
|
|
|
|
|
|
|
|
|||
Long-term investments - rabbi trust |
|
|
|
|
|
|
|
|
|
|||
Long-term note receivable |
|
|
|
|
|
|
|
|
|
|||
Deferred income taxes |
|
|
|
|
|
|
|
|
|
|||
Other assets |
|
|
|
|
|
|
|
|
|
|||
Total assets |
|
$ |
|
|
$ |
|
|
$ |
|
|||
|
|
|
|
|
|
|
|
|
|
|||
Current liabilities: |
|
|
|
|
|
|
|
|
|
|||
Line of credit |
|
$ |
|
|
$ |
- |
|
|
$ |
- |
|
|
Accounts payable - trade |
|
|
|
|
|
|
|
|
|
|||
Accounts payable - capital expenditures |
|
|
|
|
|
|
|
|
|
|||
Operating lease liability - current |
|
|
|
|
|
|
|
|
|
|||
Deferred compensation - current |
|
|
|
|
|
|
|
|
|
|||
Deferred revenue |
|
|
|
|
|
|
|
|
|
|||
Accrued expenses |
|
|
|
|
|
|
|
|
|
|||
Accrued restructuring |
|
|
|
|
|
|
|
|
— |
|
||
Income taxes payable - current |
|
|
|
|
|
|
|
|
|
|||
Total current liabilities |
|
|
|
|
|
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
|
|||
Operating lease liability - long-term |
|
|
|
|
|
|
|
|
|
|||
Income taxes payable - long-term |
|
|
|
|
|
|
|
|
|
|||
Deferred income taxes |
|
|
|
|
|
|
|
|
|
|||
Deferred compensation - long-term |
|
|
|
|
|
|
|
|
|
|||
Total liabilities |
|
|
|
|
|
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
||||
Shareholders' equity |
|
|
|
|
|
|
|
|
|
|||
Preferred stock, $ |
|
|
|
|
|
|
|
|
|
|||
Common stock, $ |
|
|
|
|
|
|
|
|
|
|||
Capital contributed in excess of par value |
|
|
|
|
|
|
|
|
|
|||
Accumulated earnings |
|
|
|
|
|
|
|
|
|
|||
Accumulated other comprehensive income |
|
|
|
|
|
|
|
|
|
|||
Total shareholders' equity |
|
|
|
|
|
|
|
|
|
|||
Total liabilities and shareholders' equity |
|
$ |
|
|
$ |
|
|
$ |
|
|||
*
See accompanying notes to consolidated financial statements.
I-3
CULP, INC.
CONSOLIDATED STATEMENTS OF CASH FLOWS
FOR THE THREE MONTHS ENDED JULY 28, 2024, AND JULY 30, 2023
UNAUDITED
(Amounts in Thousands)
|
|
THREE MONTHS ENDED |
|
|||||
|
|
July 28, |
|
|
July 30, |
|
||
|
|
2024 |
|
|
2023 |
|
||
Cash flows from operating activities: |
|
|
|
|
|
|
||
Net loss |
|
$ |
( |
) |
|
$ |
( |
) |
Adjustments to reconcile net loss to net cash used in |
|
|
|
|
|
|
||
Depreciation |
|
|
|
|
|
|
||
Non-cash inventory credit |
|
|
( |
) |
|
|
( |
) |
Amortization |
|
|
|
|
|
|
||
Stock-based compensation |
|
|
|
|
|
|
||
Deferred income taxes |
|
|
|
|
|
( |
) |
|
Gain on sale of equipment |
|
|
( |
) |
|
|
( |
) |
Non-cash restructuring expenses |
|
|
|
|
|
|
||
Foreign currency exchange (loss) gain |
|
|
|
|
|
( |
) |
|
Changes in assets and liabilities: |
|
|
|
|
|
|
||
Accounts receivable |
|
|
( |
) |
|
|
|
|
Inventories |
|
|
|
|
|
|
||
Other current assets |
|
|
( |
) |
|
|
( |
) |
Other assets |
|
|
|
|
|
( |
) |
|
Accounts payable – trade |
|
|
|
|
|
( |
) |
|
Deferred revenue |
|
|
|
|
|
( |
) |
|
Accrued restructuring |
|
|
|
|
|
|
||
Accrued expenses and deferred compensation |
|
|
( |
) |
|
|
( |
) |
Income taxes |
|
|
( |
) |
|
|
( |
) |
Net cash used in provided by operating activities |
|
|
( |
) |
|
|
( |
) |
Cash flows from investing activities: |
|
|
|
|
|
|
||
Capital expenditures |
|
|
( |
) |
|
|
( |
) |
Proceeds from the sale of equipment |
|
|
|
|
|
|
||
Proceeds from note receivable |
|
|
|
|
|
|
||
Proceeds from the sale of investments (rabbi trust) |
|
|
|
|
|
|
||
Purchase of investments (rabbi trust) |
|
|
( |
) |
|
|
( |
) |
Net cash (used in) provided by investing activities |
|
|
( |
) |
|
|
|
|
Cash flows from financing activities: |
|
|
|
|
|
|
||
Procceds from line credit - China |
|
|
|
|
|
— |
|
|
Net cash provided by financing activities |
|
|
|
|
|
— |
|
|
Effect of exchange rate changes on cash and cash equivalents |
|
|
( |
) |
|
|
( |
) |
Increase (decrease) in cash and cash equivalents |
|
|
|
|
|
( |
) |
|
Cash and cash equivalents at beginning of period |
|
|
|
|
|
|
||
Cash and cash equivalents at end of period |
|
$ |
|
|
$ |
|
||
See accompanying notes to consolidated financial statements.
I-4
CULP, INC.
FOR THE THREE MONTHS ENDED JULY 28, 2024
UNAUDITED
(Dollars in thousands, except share data)
|
|
|
|
|||||||||||||||||||||
|
|
|
|
|
|
|
|
Capital |
|
|
|
|
|
Accumulated |
|
|
|
|
||||||
|
|
|
|
|
|
|
|
Contributed |
|
|
|
|
|
Other |
|
|
Total |
|
||||||
|
|
Common Stock |
|
|
in Excess |
|
|
Accumulated |
|
|
Comprehensive |
|
|
Shareholders' |
|
|||||||||
|
|
Shares |
|
|
Amount |
|
|
of Par Value |
|
|
Earnings |
|
|
Income |
|
|
Equity |
|
||||||
Balance, April 28, 2024 * |
|
|
|
|
$ |
|
|
$ |
|
|
$ |
|
|
$ |
|
|
$ |
|
||||||
Net loss |
|
|
— |
|
|
|
— |
|
|
|
— |
|
|
|
( |
) |
|
|
— |
|
|
|
( |
) |
Stock-based compensation |
|
|
— |
|
|
|
— |
|
|
|
|
|
|
— |
|
|
|
— |
|
|
|
|
||
Unrealized gain on investments |
|
|
— |
|
|
|
— |
|
|
|
— |
|
|
|
— |
|
|
|
|
|
|
|
||
Balance, July 28, 2024 |
|
|
|
|
$ |
|
|
$ |
|
|
$ |
|
|
$ |
|
|
$ |
|
||||||
*
See accompanying notes to consolidated financial statements
I-5
CULP, INC.
FOR THE THREE MONTHS ENDED JULY 30, 2023
UNAUDITED
(Dollars in thousands, except share data)
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||
|
|
|
|
|
|
|
|
Capital |
|
|
|
|
|
Accumulated |
|
|
|
|
||||||
|
|
|
|
|
|
|
|
Contributed |
|
|
|
|
|
Other |
|
|
Total |
|
||||||
|
|
Common Stock |
|
|
in Excess |
|
|
Accumulated |
|
|
Comprehensive |
|
|
Shareholders' |
|
|||||||||
|
|
Shares |
|
|
Amount |
|
|
of Par Value |
|
|
Earnings |
|
|
Income |
|
|
Equity |
|
||||||
Balance, April 30, 2023 * |
|
|
|
|
$ |
|
|
$ |
|
|
$ |
|
|
$ |
|
|
$ |
|
||||||
Net loss |
|
|
— |
|
|
|
— |
|
|
|
— |
|
|
|
( |
) |
|
|
— |
|
|
|
( |
) |
Stock-based compensation |
|
|
— |
|
|
|
— |
|
|
|
|
|
|
— |
|
|
|
— |
|
|
|
|
||
Unrealized gain on investments |
|
|
— |
|
|
|
— |
|
|
|
— |
|
|
|
— |
|
|
|
|
|
|
|
||
Immediately vested common stock award |
|
|
|
|
|
|
|
|
( |
) |
|
|
— |
|
|
|
— |
|
|
|
— |
|
||
Balance, July 30, 2023 |
|
|
|
|
$ |
|
|
$ |
|
|
$ |
|
|
$ |
|
|
$ |
|
||||||
*
See accompanying notes to consolidated financial statements.
I-6
Culp, Inc.
NOTES TO CONSOLIDATED FINANCIAL STATEMENTS
(Unaudited)
1. Basis of Presentation
The accompanying unaudited condensed consolidated financial statements of Culp, Inc. and its majority-owned subsidiaries (the “company”) include all adjustments that are, in the opinion of management, necessary for fair presentation of the results of operations and financial position. All these adjustments are of a normal recurring nature. Results of operations for interim periods may not be indicative of future results. The unaudited condensed consolidated financial statements should be read in conjunction with the audited consolidated financial statements that are included in the company’s annual report on Form 10-K filed with the Securities and Exchange Commission on July 12, 2024, for the fiscal year ended April 28, 2024.
The company's three-months ended July 28, 2024, and July 30, 2023, each represent 13-week periods.
2. Significant Accounting Policies
As of July 28, 2024, there were no changes in the nature of our significant accounting policies or the application of those policies from those reported in our annual report on Form 10-K for the year then ended April 28, 2024.
Recently Adopted Accounting Pronouncements
There were no recently adopted accounting pronouncements during the first quarter of fiscal 2025.
Recently Issued Accounting Pronouncements
Effective November 27, 2023, the Financial Accounting Standards Board ("FASB") issued Accounting Standards Update ("ASU") 2023-07 Improvements to Reportable Segment Disclosures which enhances disclosure requirements to segment reporting including (i) significant segment expenses that are regularly provided to the Chief Operating Decision Maker (CODM) that are included within each measure of segment profit or loss, (ii) other segment items by reportable segment as defined by ASU 2023-07, and (iii) the title and position of the CODM and an explanation of how the CODM uses the reported measure(s) of each segment's profit or loss in assessing segment performance and deciding how to allocate resources. ASU 2023-07 is effective for public entities starting in annual periods beginning after December 15, 2023 (i.e., our fiscal 2025 annual report) and interim periods beginning after December 15, 2024 (i.e., first quarter of fiscal 2026 interim report). The company expects that the adoption ASU 2023-07 will not have an impact on our results of operations and financial condition, but will have a material impact on the disclosures required in the notes to the consolidated financial statements, which are disclosed in Note 13.
Effective December 14, 2023, the FASB issued ASU 2023-09 Improvements to Income Tax Disclosures, which is an update to Topic 740, Income Taxes. The amendments in this update relate to improvements regarding the transparency of income tax disclosures by requiring consistent categories and greater disaggregation by jurisdiction of information included in the effective income tax rate reconciliation and for income taxes paid. Also, the amendments allow investors to better assess an entity's (i) capital allocation decisions, (ii) worldwide operations, and (iii) related tax risks, tax planning, and operational opportunities that affect the effective income tax rate and prospects for future cash flows. The other amendments in this update improve the effectiveness and comparability of disclosures relating to pretax income (or loss) and income tax expense (or benefit) and remove disclosures that are no longer considered cost beneficial or relevant. ASU 2023-09 is effective for public entities starting in annual periods beginning after December 15, 2024 (i.e., our fiscal 2026 annual report). Early adoption is permitted. The company expects that the adoption ASU 2023-09 will not have an impact on our results of operations and financial condition, but will have a material impact on the disclosures required in the notes to the consolidated financial statements, which are disclosed in Note 14.
Currently, there are no new accounting pronouncements that are expected to have a material effect on our consolidated financial statements.
I-7
3. Allowance for Doubtful Accounts
A summary of the activity in the allowance for doubtful accounts follows:
|
|
Three months ended |
|
|||||
(dollars in thousands) |
|
July 28, 2024 |
|
|
July 30, 2023 |
|
||
Beginning balance |
|
$ |
|
|
$ |
|
||
Provision for bad debts |
|
|
|
|
|
|
||
Write-offs, net of recoveries |
|
|
— |
|
|
|
( |
) |
Ending balance |
|
$ |
|
|
$ |
|
||
|
|
|
|
|
|
|
||
During the three-month periods ended July 28, 2024, and July 30, 2023, we assessed the credit risk of our customers within our accounts receivable portfolio. Our risk assessment includes the respective customers’ (i) financial position; (ii) past payment history; (iii) management’s general ability; and (iv) historical loss experience; as well as (v) any other ongoing economic conditions. After our risk assessment was completed, we assigned credit grades to our customers, which in turn, were used to determine our allowance for doubtful accounts totaling $
4. Revenue from Contracts with Customers
Nature of Performance Obligations
Our operations are classified into
Our primary performance obligations include the sale of mattress fabrics and upholstery fabrics, as well as the performance of customized fabrication and installation services for Read’s products associated with window treatments.
Contract Assets & Liabilities
Certain contracts, primarily those for customized fabrication and installation services associated with Read, require payments in advance in the form of customer deposits that result in a contract liability which is recorded in the Consolidated Balance Sheets as deferred revenue. If payments in advance are not required, customers may be granted terms which generally range from
A summary of the activity associated with deferred revenue follows:
|
|
Three months ended |
|
|||||
(dollars in thousands) |
|
July 28, 2024 |
|
|
July 30, 2023 |
|
||
Beginning balance |
|
$ |
|
|
$ |
|
||
Revenue recognized on contract liabilities |
|
|
( |
) |
|
|
( |
) |
Payments received for services not yet rendered |
|
|
|
|
|
|
||
Ending balance |
|
$ |
|
|
$ |
|
||
Disaggregation of Revenue
The following table presents our disaggregated revenue by segment, timing of revenue recognition, and product sales versus services rendered for the three-month period ending July 28, 2024:
|
|
Mattress |
|
|
Upholstery |
|
|
|
|
|||
(dollars in thousands) |
|
Fabrics |
|
|
Fabrics |
|
|
Total |
|
|||
Products transferred at a point in time |
|
$ |
|
|
$ |
|
|
$ |
|
|||
Services transferred over time |
|
|
— |
|
|
|
|
|
|
|
||
Total Net Sales |
|
$ |
|
|
$ |
|
|
$ |
|
|||
I-8
The following table presents our disaggregated revenue by segment, timing of revenue recognition, and product sales versus services rendered for the three-month period ending July 30, 2023:
|
|
Mattress |
|
|
Upholstery |
|
|
|
|
|||
(dollars in thousands) |
|
Fabrics |
|
|
Fabrics |
|
|
Total |
|
|||
Products transferred at a point in time |
|
$ |
|
|
$ |
|
|
$ |
|
|||
Services transferred over time |
|
|
— |
|
|
|
|
|
|
|
||
Total Net Sales |
|
$ |
|
|
$ |
|
|
$ |
|
|||
5. Inventories
Inventories are carried at the lower of cost or net realizable value. Cost is determined using the FIFO (first-in, first-out) method.
A summary of inventories follows:
(dollars in thousands) |
|
July 28, |
|
|
July 30, |
|
|
April 28, |
|
|||
Raw materials |
|
$ |
|
|
$ |
|
|
$ |
|
|||
Work-in-process |
|
|
|
|
|
|
|
|
|
|||
Finished goods |
|
|
|
|
|
|
|
|
|
|||
|
|
$ |
|
|
$ |
|
|
$ |
|
|||
Measurement of Inventory to Net Realizable Value
We recorded a non-cash inventory credit of $
We recorded a non-cash inventory credit of $
Assessment
As of July 28, 2024, we reviewed our mattress fabrics and upholstery fabrics inventories to determine if any additional write-downs, in excess of the amount recorded based on our policy for aged inventory, were necessary. Based on our assessment, no additional write-downs of inventories to their net realizable value were recorded for the three months ended July 28, 2024, other than the markdowns of inventory associated with our restructuring activities described in Note 9 of the consolidated financial statements.
Based on the current unfavorable macroeconomic conditions, it is possible that estimates used by management to determine the write down of inventory to its net realizable value could be materially different from the actual amounts or our results. These differences could result in higher than expected inventory provisions, which could adversely affect the company’s results of operations and financial condition in the near term.
6. Intangible Assets
A summary of intangible assets follows:
(dollars in thousands) |
|
July 28, |
|
|
July 30, |
|
|
April 28, |
|
|||
Tradename |
|
$ |
|
|
$ |
|
|
$ |
|
|||
Customer relationships, net |
|
|
|
|
|
|
|
|
|
|||
Non-compete agreement, net |
|
|
|
|
|
|
|
|
|
|||
|
|
$ |
|
|
$ |
|
|
$ |
|
|||
I-9
Tradename
Our tradename pertains to Read, a separate reporting unit within the upholstery fabrics segment. This tradename was determined to have an indefinite useful life at the time of its acquisition, and therefore is not being amortized. However, we are required to assess this tradename annually or between annual tests if we believe indicators of impairment exist. Based on our assessment as of July 28, 2024, no indicators of impairment existed, and therefore we did
Customer Relationships
A summary of the change in the carrying amount of our customer relationships follows:
|
|
Three months ended |
|
|||||
(dollars in thousands) |
|
July 28, 2024 |
|
|
July 30, 2023 |
|
||
Beginning balance |
|
$ |
|
|
$ |
|
||
Amortization expense |
|
|
( |
) |
|
|
( |
) |
Ending balance |
|
$ |
|
|
$ |
|
||
Our customer relationships are amortized on a straight-line basis over useful lives ranging from to
The gross carrying amount of our customer relationships was $
The remaining amortization expense for the next five fiscal years and thereafter are as follows: FY 2025 - $
The weighted average amortization period for our customer relationships was
Non-Compete Agreement
A summary of the change in the carrying amount of our non-compete agreement follows:
|
|
Three months ended |
|
|||||
(dollars in thousands) |
|
July 28, 2024 |
|
|
July 30, 2023 |
|
||
Beginning balance |
|
$ |
|
|
$ |
|
||
Amortization expense |
|
|
( |
) |
|
|
( |
) |
Ending balance |
|
$ |
|
|
$ |
|
||
Our non-compete agreement is associated with a prior acquisition by our mattress fabrics segment and is amortized on a straight-line basis over the
The gross carrying amount of our non-compete agreement was $
The remaining amortization expense for the next five years and thereafter follows: FY 2025 - $
The weighted average amortization period for the non-compete agreement was
Impairment of Definite Lived Assets - Mattress Fabrics Segment
As of July 28, 2024, management reviewed the long-lived assets associated with our mattress fabrics segment, which consisted of property, plant, and equipment, right of use assets, and definite-lived intangible assets (collectively known as the "Mattress Asset Group"), for impairment, as events and changes in circumstances occurred that indicated the carrying amount of the Mattress Asset Group may not be recoverable. The mattress fabrics segment experienced a significant cumulative operating loss totaling $
I-10
believe was driven by the following factors: (i) inflationary effects of commodities such as gas, food, and other necessities; (ii) a significant increase in interest rates; (iii) the pulling forward of demand for home goods products during the early years of the COVID-19 pandemic, which demand has now shifted to travel, leisure, and other services; and (iv) excess inventory held by customers due to the decline in consumer demand.
Based on the above evidence, we were required to determine the recoverability of the Mattress Asset Group, which is classified as held and used, by comparing the carrying amount of the Mattress Asset Group to the sum of the future undiscounted cash flows expected to result from its use and eventual disposition. If the carrying amount of an asset group exceeds its estimated future cash flows, an impairment charge is recognized for the excess of the carrying amount over the fair value of the asset group. The carrying amount of the Mattress Asset Group totaled $
7. Note Receivable
In connection with the restructuring activity of our upholstery fabrics cut and sew operation located in Ouanaminthe, Haiti, effective January 24, 2023, Culp Upholstery Fabrics Haiti, Ltd. (“CUF Haiti”) entered into an agreement to terminate a lease of a facility (“Termination Agreement”). See Note 9 of the consolidated financial statements for further details regarding this restructuring activity.
Pursuant to the terms of the original lease agreement (the “Original Lease”), CUF Haiti was required to pay in advance $
As of the end of our third quarter of fiscal 2023, the carrying amount of the note receivable totaling $
Effective May 1, 2024, CUF Haiti formally assigned the $
The following table represents the remaining future principal payments as of July 28, 2024:
(dollars in thousands) |
|
|
|
|
2025 |
|
$ |
|
|
2026 |
|
|
|
|
2027 |
|
|
|
|
2028 |
|
|
|
|
2029 |
|
|
|
|
Thereafter |
|
|
|
|
Undiscounted value of note receivable |
|
$ |
|
|
Less: unearned interest income |
|
|
( |
) |
Present value of note receivable |
|
$ |
|
|
I-11
As of July 28, 2024, note receivable totaled $
We classified amortization of unearned interest income totaling $
As of July 28, 2024, we believe there is no expected credit loss related to the collectibility of our note receivable, as the Lessee has made all of the required principal payments stated in the Termination Agreement. We will continue to evaluate the facts and circumstances at the end of each reporting period to determine if an expected credit loss is deemed necessary.
8. Accrued Expenses
A summary of accrued expenses follows:
(dollars in thousands) |
|
July 28, |
|
|
July 30, |
|
|
April 28, |
|
|||
Compensation, commissions and related benefits |
|
$ |
|
|
$ |
|
|
$ |
|
|||
Other accrued expenses |
|
|
|
|
|
|
|
|
|
|||
|
|
$ |
|
|
$ |
|
|
$ |
|
|||
9. Restructuring Activities
Mattress Fabrics Segment, Upholstery Fabrics Segment, and Unallocated Corporate
Fiscal 2025 Restructuring Plan
On April 29, 2024 (first quarter of fiscal 2025), our board of directors made a decision to (1) consolidate the company's North American mattress fabrics operations, including a gradual discontinuation of operations and sale of the company's manufacturing facility located in Quebec, Canada; (2) move a portion of the knitting and finishing capacity from the company's manufacturing facility located in Quebec, Canada to the company's manufacturing facility located in Stokesdale, NC; (3) transition the mattress fabrics segment's weaving operation to a strategic sourcing model through the company's long standing supply partners; (4) consolidate the company's two leased facilities related to the sewn mattress cover operation located in Ouanaminthe, Haiti, and reduce other operating expenses at this location; as well as (5) reduce unallocated corporate expenses and shared service expenses.
We expect the gradual discontinuance of operations and the closure of the facility located in Quebec, Canada will be completed by December 31, 2024. The consolidation activity associated with the sewn mattress cover operation located in Haiti was completed during the first quarter of fiscal 2025. During fiscal 2025, these actions are expected to result in restructuring and restructuring related charges of approximately $
The $
I-12
Based on changes in business and current industry economic conditions, it is possible that the above estimates provided by management to determine restructuring and restructuring related charges incurred during fiscal 2025, and proceeds generated from the sale of the manufacturing facility located in Quebec, Canada, could be materially different from our actual results, and therefore could adversely affect the success of this restructuring plan.
The following summarizes accrued restructuring costs for the three-month period ending July 28, 2024:
|
|
Employee |
|
|
Other |
|
|
|
|
|||
|
|
Termination |
|
|
Associated |
|
|
|
|
|||
(dollars in thousands) |
|
Benefits |
|
|
Costs |
|
|
Total |
|
|||
Beginning balance |
|
$ |
— |
|
|
$ |
— |
|
|
$ |
— |
|
Expenses incurred |
|
|
|
|
|
|
|
|
|
|||
Change in estimate adjustments |
|
|
— |
|
|
|
— |
|
|
|
— |
|
Payments |
|
|
( |
) |
|
|
( |
) |
|
|
( |
) |
Foreign currency exchange remeasurement |
|
|
( |
) |
|
|
— |
|
|
|
( |
) |
Ending balance |
|
$ |
|
|
$ |
|
|
$ |
|
|||
The following summarizes the restructuring and restructuring related charges for the three-month period ending July 28, 2024:
|
|
|
Three Months Ended |
|
|
(dollars in thousands) |
|
|
July 28, 2024 |
|
|
Additional depreciation expense for shortened useful lives of equipment |
|
|
$ |
|
|
Employee termination benefits |
|
|
|
|
|
Lease termination costs |
|
|
|
|
|
Other Associated Costs |
|
|
|
|
|
Loss on disposal and markdowns of inventory |
|
|
|
|
|
Impairment and loss on disposal of equipment |
|
|
|
|
|
Restructuring expense and restructuring related charges (1) |
|
|
$ |
|
|
(1)
A summary of assets held for sale as of July 28, 2024 follows:
|
|
|
|
|
|
(dollars in thousands) |
|
|
July 28, 2024 |
|
|
Equipment (1) |
|
|
$ |
|
|
Right of use asset (2) |
|
|
|
|
|
Ending Balance |
|
|
$ |
|
|
(1)
(2)
I-13
Upholstery Fabrics Segment
Shanghai, China
Upholstery Fabrics Finishing Operation
During the fourth quarter of fiscal 2024, we closed our upholstery fabrics finishing operation to align with current demand trends and will continue to leverage our strategic supply relationships to meet customer finishing needs in China. This restructuring activity was completed during the first quarter of fiscal 2025 and resulted in cumulative restructuring and restructuring related charges totaling $
The following summarizes the activity in accrued restructuring costs for the three-month period ending July 28, 2024:
(dollars in thousands) |
Total |
|
|
Beginning balance (1) |
$ |
|
|
Expenses incurred (2) |
|
|
|
Payments |
|
( |
) |
Ending balance (3) |
$ |
|
|
(1)
(2)
(3)
Ouanaminthe, Haiti
Cut and Sew Upholstery Fabrics Operation
During the third quarter of fiscal 2023, Culp Upholstery Fabrics Haiti, Ltd. ("CUF Haiti") entered into an agreement to terminate a lease associated with a facility, and in turn moved the production of upholstery cut and sewn kits to an existing facility leased by Culp Home Fashions Haiti, Ltd. ("CHF Haiti") during the fourth quarter of fiscal 2023. Both CUF Haiti and CHF Haiti are indirectly wholly-owned subsidiaries of the company. During the first quarter of fiscal 2024, demand for upholstery cut and sewn kits declined more than previously anticipated, resulting in the strategic action to discontinue the production of upholstery cut and sew kits in Haiti.
The following summarizes our restructuring expense and restructuring related charges for the three months ending July 30, 2023:
|
|
|
Three Months Ended |
|
|
(dollars in thousands) |
|
|
July 30, 2023 |
|
|
Employee termination benefits |
|
|
$ |
|
|
Impairment loss - equipment |
|
|
|
|
|
Loss on disposal and markdowns of inventory |
|
|
|
|
|
Restructuring expense and restructuring related charges (1) |
|
|
$ |
|
|
(1)
This restructuring activity was completed during the third quarter of fiscal 2024 and resulted in a cumulative restructuring and restructuring related charges of $
10
Revolving Credit Agreement – United States
I-14
Culp, Inc., as borrower (the “borrower”), and Read, the guarantor (the “Guarantor”), entered into an agreement (the "ABL Credit Agreement") by and among the borrower, the Guarantor and Wells Fargo Bank, National Association, as the lender (the “Lender”), to establish an asset-based revolving credit facility (the “ABL Facility”). The proceeds from the ABL Facility may be used to pay fees and expenses related to the ABL Facility and will provide funding for ongoing working capital and general corporate purposes.
The ABL Facility may be used for revolving credit loans and letters of credit from time to time up to a maximum principal amount of $
In each case, the net-orderly-liquidation value is calculated based on the lower of (i) a first-in first-out basis and (ii) market value, and is (A) net of intercompany profits, (B) net of write-ups and write-downs in value with respect to foreign currency exchange rates and (C) consistent with most recent appraisals received and acceptable to Lender.
minus
The ABL Facility matures on
The borrower’s obligations under the ABL Facility (and certain related obligations) are guaranteed by the Guarantor. In addition, the ABL Credit Agreement requires that the borrower's future domestic subsidiaries guarantee the ABL Facility on a senior secured basis (such future domestic subsidiaries, together with the Guarantor and the borrower, the "Loan Parties"). The borrower's obligations under the ABL Facility are secured by first priority liens and other security interests on all assets of the Loan Parties, subject to certain exceptions and permitted liens.
I-15
Cash Dominion. Under the terms of the ABL Facility, if (i) an event of default has occurred or (ii) excess borrowing availability under the ABL Facility (based on the lesser of $
Financial Covenants. The ABL Facility contains a springing covenant requiring that the company’s fixed charge coverage ratio be no less than
Affirmative and Restrictive Covenants. The ABL Credit Agreement governing the ABL Facility contains customary representations and warranties, affirmative and negative covenants (subject, in each case, to exceptions and qualifications), and events of defaults, including covenants that limit the company’s ability to, among other things:
Overall
Interest is charged at a rate (applicable interest rate of
There were $
There were
As of July 28, 2024, our available borrowings calculated under the provisions of the ABL Credit Agreement totaled $
Revolving Credit Agreement – China Operations
Denominated in Chinese Yuan Renminbi (“RMB”)
Agricultural Bank of China
Effective on March 20, 2024, we entered into an unsecured credit agreement denominated in RMB, that provides for a line of credit up to
I-16
Interest charged under this agreement is based on the Loan Prime Rate ("LPR") in China minus
As of July 28, 2024, the amount outstanding was
Bank of China
We have an unsecured credit agreement denominated in RMB that provides for a line of credit of up to
There were
Overall
Our loan agreements require, among other things, that we maintain compliance with certain financial covenants. As of July 28 , 2024, we were in compliance with our financial covenants.
11. Fair Value
ASC Topic 820 establishes a fair value hierarchy that distinguishes between assumptions based on market data (observable inputs) and the company’s assumptions (unobservable inputs). Determining where an asset or liability falls within that hierarchy depends on the lowest level input that is significant to the fair value measurement as a whole. An adjustment to the pricing method used within either level 1 or level 2 inputs could generate a fair value measurement that effectively falls in a lower level in the hierarchy.
The hierarchy consists of three broad levels as follows:
Level 1 – Quoted market prices in active markets for identical assets or liabilities;
Level 2 – Inputs other than level 1 inputs that are either directly or indirectly observable; and
Level 3 – Unobservable inputs developed using the company’s estimates and assumptions, which reflect those that market participants would use.
The determination of where an asset or liability falls in the hierarchy requires significant judgment. We evaluate our hierarchy disclosures each quarter based on various factors, and it is possible that an asset or liability may be classified differently from quarter to quarter. However, we expect that changes in classifications between different levels will be rare.
Recurring Basis
The following tables present information about assets measured at fair value on a recurring basis:
|
|
Fair value measurements as of July 28, 2024, using: |
|
|||||||||
|
|
Quoted prices |
|
|
Significant |
|
|
|
|
|
||
|
|
in active |
|
|
other |
|
Significant |
|
|
|
||
|
|
markets for |
|
|
observable |
|
unobservable |
|
|
|
||
|
|
identical assets |
|
|
inputs |
|
inputs |
|
|
|
||
(amounts in thousands) |
|
Level 1 |
|
|
Level 2 |
|
Level 3 |
|
Total |
|
||
Assets: |
|
|
|
|
|
|
|
|
|
|
||
U.S. Government Money Market Fund |
|
$ |
|
|
N/A |
|
N/A |
|
$ |
|
||
Growth Allocation Mutual Funds |
|
|
|
|
N/A |
|
N/A |
|
|
|
||
S&P 500 Index Fund |
|
|
|
|
N/A |
|
N/A |
|
|
|
||
Moderate Allocation Mutual Fund |
|
|
|
|
N/A |
|
N/A |
|
|
|
||
Other |
|
|
|
|
N/A |
|
N/A |
|
|
|
||
I-17
|
|
Fair value measurements as of July 30, 2023, using: |
|
|||||||||
|
|
Quoted prices |
|
|
Significant |
|
|
|
|
|
||
|
|
in active |
|
|
other |
|
Significant |
|
|
|
||
|
|
markets for |
|
|
observable |
|
unobservable |
|
|
|
||
|
|
identical assets |
|
|
inputs |
|
inputs |
|
|
|
||
(amounts in thousands) |
|
Level 1 |
|
|
Level 2 |
|
Level 3 |
|
Total |
|
||
Assets: |
|
|
|
|
|
|
|
|
|
|
||
U.S. Government Money Market Fund |
|
$ |
|
|
N/A |
|
N/A |
|
$ |
|
||
Growth Allocation Mutual Funds |
|
|
|
|
N/A |
|
N/A |
|
|
|
||
S&P 500 Index Fund |
|
|
|
|
N/A |
|
N/A |
|
|
|
||
Moderate Allocation Mutual Fund |
|
|
|
|
N/A |
|
N/A |
|
|
|
||
Other |
|
|
|
|
N/A |
|
N/A |
|
|
|
||
|
|
Fair value measurements as of April 28, 2024, using: |
|
|||||||||
|
|
Quoted prices |
|
|
Significant |
|
|
|
|
|
||
|
|
in active |
|
|
other |
|
Significant |
|
|
|
||
|
|
markets for |
|
|
observable |
|
unobservable |
|
|
|
||
|
|
identical assets |
|
|
inputs |
|
inputs |
|
|
|
||
(amounts in thousands) |
|
Level 1 |
|
|
Level 2 |
|
Level 3 |
|
Total |
|
||
Assets: |
|
|
|
|
|
|
|
|
|
|
||
U.S. Government Money Market Fund |
|
$ |
|
|
N/A |
|
N/A |
|
$ |
|
||
Growth Allocation Mutual Funds |
|
|
|
|
N/A |
|
N/A |
|
|
|
||
S&P 500 Index Fund |
|
|
|
|
N/A |
|
N/A |
|
|
|
||
Moderate Allocation Mutual Fund |
|
|
|
|
N/A |
|
N/A |
|
|
|
||
Other |
|
|
|
|
N/A |
|
N/A |
|
|
|
||
Investments - Rabbi Trust
We have a rabbi trust (the “Trust”) for the participants of our deferred compensation plan (the “Plan”), that enables participants to direct their contributions to various investment options under the Plan. The investments associated with the Trust consist of a money market fund and various mutual funds that are classified as available-for-sale.
As of July 28, 2024, our investments associated with the Trust totaled $
The fair value of our long-term investments associated with the Trust approximates their cost basis.
Other
The carrying amount of our cash and cash equivalents, accounts receivable, other current assets, accounts payable, and accrued expenses approximated their fair value because of the short maturity of these financial instruments.
12. Net Loss Per Share
Basic net loss per share is computed using the weighted-average number of shares outstanding during the period. Diluted net loss per share uses the weighted-average number of shares outstanding during the period plus the dilutive effect of stock-based compensation calculated using the treasury stock method.
Weighted average shares used in the computation of basic and diluted net loss per share were
Shares of unvested common stock that were not included in the computation of diluted net loss per share consist of the following:
I-18
|
|
Three Months Ended |
|
|||||
(in thousands) |
|
July 28, 2024 |
|
|
July 30, 2023 |
|
||
Antidilutive effect from decrease in the price per share of our common stock |
|
|
|
|
||||
Antidilutive effect from net loss incurred during the fiscal quarter |
|
|
|
|
||||
Total unvested shares of common stock not included in |
|
|
|
|
|
|
||
computation of diluted net loss per share |
|
|
|
|
|
|
||
13. Segment Information
Overall
Our operations are classified into
Mattress Fabrics
The mattress fabrics segment manufactures, sources, and sells fabrics and mattress covers primarily to bedding manufacturers.
Upholstery Fabrics
The upholstery fabrics segment develops, manufactures, sources, and sells fabrics to customers in the residential, commercial, and hospitality industries. In addition, this segment includes Read, which provides window treatments and sourcing of upholstery fabrics and other products, as well as measuring and installation services for Read’s products, to customers in the hospitality and commercial industries. Read also supplies soft goods such as decorative top sheets, coverlets, duvet covers, bed skirts, bolsters, and pillows.
Financial Information
We evaluate the operating performance of our business segments based upon (loss) income from operations before certain unallocated corporate expenses and other items that are not expected to occur on a regular basis. Cost of sales for each segment includes costs to develop, manufacture, or source our products, including costs such as raw material and finished goods purchases, direct and indirect labor, overhead, and incoming freight charges. Unallocated corporate expenses primarily represent compensation and benefits for certain executives and their support staff, all costs associated with being a public company, amortization of intangible assets, and other miscellaneous expenses. Segment assets include assets used in the operations of each segment and consist of accounts receivable, inventories, property, plant, and equipment, and right of use assets. The mattress fabrics segment also includes assets held for sale associated with a right of use asset and equipment related to the fiscal 2025 restructuring plan announced on April 29, 2024 (see Note 9 to the consolidated financial statements for further details regarding this restructuring plan).
I-19
Statements of operations for our operating segments are as follows:
|
|
Three months ended |
|
|||||
|
|
July 28, 2024 |
|
|
July 30, 2023 |
|
||
Net sales by segment: |
|
|
|
|
|
|
||
Mattress fabrics |
|
$ |
|
|
$ |
|
||
Upholstery fabrics |
|
|
|
|
|
|
||
Net sales |
|
$ |
|
|
$ |
|
||
Gross (loss) profit: |
|
|
|
|
|
|
||
Mattress fabrics |
|
$ |
( |
) |
|
$ |
|
|
Upholstery fabrics |
|
|
|
|
|
|
||
Segment gross profit |
|
|
|
|
|
|
||
Restructuring related charge (1) (3) |
|
|
( |
) |
|
|
( |
) |
Gross profit |
|
$ |
|
|
$ |
|
||
Selling, general, and administrative expenses by segment: |
|
|
|
|
|
|
||
Mattress fabrics |
|
$ |
|
|
$ |
|
||
Upholstery fabrics |
|
|
|
|
|
|
||
Unallocated corporate expenses |
|
|
|
|
|
|
||
Selling, general, and administrative expenses |
|
$ |
|
|
$ |
|
||
(Loss) income from operations by segment: |
|
|
|
|
|
|
||
Mattress fabrics |
|
$ |
( |
) |
|
$ |
( |
) |
Upholstery fabrics |
|
|
|
|
|
|
||
Unallocated corporate expenses |
|
|
( |
) |
|
|
( |
) |
Total segment loss from operations |
|
$ |
( |
) |
|
$ |
( |
) |
Restructuring related charge (1) (3) |
|
|
( |
) |
|
|
( |
) |
Restructuring expense (2) (4) |
|
|
( |
) |
|
|
( |
) |
Loss from operations |
|
$ |
( |
) |
|
$ |
( |
) |
Interest expense |
|
|
( |
) |
|
|
— |
|
Interest income |
|
|
|
|
|
|
||
Other (expense) income |
|
|
( |
) |
|
|
|
|
Loss before income taxes |
|
$ |
( |
) |
|
$ |
( |
) |
(1)
(2)
(3)
(4)
I-20
Balance sheet information for our operating segments follows:
(dollars in thousands) |
|
July 28, 2024 |
|
|
July 30, 2023 |
|
|
April 28, 2024 |
|
|||
Segment assets: |
|
|
|
|
|
|
|
|
|
|||
Mattress Fabrics: |
|
|
|
|
|
|
|
|
|
|||
Accounts receivable |
|
$ |
|
|
$ |
|
|
$ |
|
|||
Inventory |
|
|
|
|
|
|
|
|
|
|||
Property, plant and equipment (5) |
|
|
|
|
|
|
|
|
|
|||
Right of use assets (6) |
|
|
|
|
|
|
|
|
|
|||
Assets held for sale |
|
|
|
|
|
— |
|
|
|
— |
|
|
Total mattress fabrics assets |
|
|
|
|
|
|
|
|
|
|||
Upholstery Fabrics: |
|
|
|
|
|
|
|
|
|
|||
Accounts receivable |
|
|
|
|
|
|
|
|
|
|||
Inventory |
|
|
|
|
|
|
|
|
|
|||
Property, plant and equipment (7) |
|
|
|
|
|
|
|
|
|
|||
Right of use assets (8) |
|
|
|
|
|
|
|
|
|
|||
Total upholstery fabrics assets |
|
|
|
|
|
|
|
|
|
|||
Total segment assets |
|
|
|
|
|
|
|
|
|
|||
Non-segment assets: |
|
|
|
|
|
|
|
|
|
|||
Cash and cash equivalents |
|
|
|
|
|
|
|
|
|
|||
Short-term investments - rabbi trust |
|
|
|
|
|
|
|
|
|
|||
Short-term note receivable |
|
|
|
|
|
|
|
|
|
|||
Current income taxes receivable |
|
|
|
|
|
|
|
|
|
|||
Other current assets |
|
|
|
|
|
|
|
|
|
|||
Long-term note receivable |
|
|
|
|
|
|
|
|
|
|||
Deferred income taxes |
|
|
|
|
|
|
|
|
|
|||
Property, plant and equipment (9) |
|
|
|
|
|
|
|
|
|
|||
Right of use assets (10) |
|
|
|
|
|
|
|
|
|
|||
Intangible assets |
|
|
|
|
|
|
|
|
|
|||
Long-term investments - rabbi trust |
|
|
|
|
|
|
|
|
|
|||
Other assets |
|
|
|
|
|
|
|
|
|
|||
Total assets |
|
$ |
|
|
$ |
|
|
$ |
|
|||
I-21
Information about capital expenditures and depreciation expense for our operating segments follows:
|
|
Three months ended |
|
|||||
(dollars in thousands) |
|
July 28, 2024 |
|
|
July 30, 2023 |
|
||
Capital expenditures (11): |
|
|
|
|
|
|
||
Mattress Fabrics |
|
$ |
|
|
$ |
|
||
Upholstery Fabrics |
|
|
|
|
|
|
||
Unallocated Corporate |
|
|
|
|
|
|
||
Total capital expenditures |
|
$ |
|
|
$ |
|
||
Depreciation expense: |
|
|
|
|
|
|
||
Mattress Fabrics (12) |
|
$ |
|
|
$ |
|
||
Upholstery Fabrics |
|
|
|
|
|
|
||
Total depreciation expense |
|
$ |
|
|
$ |
|
||
I-22
14. Income Taxes
Effective Income Tax Rate
We recorded income tax expense of $
Our effective income tax rates for the three-month periods ended July 28, 2024, and July 30, 2023, were based upon the estimated effective income tax rate applicable for the full year after giving effect to any significant items related specifically to interim periods. When calculating the annual estimated effective income tax rates for the three-month periods ended July 28, 2024, and July 30, 2023, we were subject to loss limitation rules. These loss limitation rules require any taxable loss associated with our U.S. or foreign operations to be excluded from the annual estimated effective income tax rate calculation if it was determined that no income tax benefit could be recognized during the current fiscal year. The effective income tax rate can be affected over the fiscal year by the mix and timing of actual earnings from our U.S. operations and foreign subsidiaries located in China, Canada, Haiti, and Vietnam versus annual projections, as well as changes in foreign currency exchange rates in relation to the U.S. dollar.
The following schedule summarizes the principal differences between income tax expense at the U.S. federal income tax rate and the effective income tax rate reflected in the consolidated financial statements for the three-month periods ending July 28, 2024, and July 30, 2023:
|
|
July 28, |
|
|
July 30, |
|
||
|
|
2024 |
|
|
2023 |
|
||
U.S. federal income tax rate |
|
|
% |
|
|
% |
||
U.S. valuation allowance |
|
|
( |
) |
|
|
( |
) |
Withholding taxes associated with foreign jurisdictions |
|
|
( |
) |
|
|
( |
) |
Foreign income tax rate differential |
|
|
|
|
|
( |
) |
|
Stock-based compensation |
|
|
( |
) |
|
|
— |
|
Tax effects of local currency foreign exchange gains |
|
|
( |
) |
|
|
|
|
Uncertain income tax positions |
|
|
|
|
|
( |
) |
|
Other |
|
|
( |
) |
|
|
|
|
|
|
( |
|
|
( |
|
||
Our consolidated effective income tax rates during the first quarter of fiscal 2025 and the first quarter of fiscal 2024 were both adversely affected by the mix of earnings between our U.S. operations and foreign subsidiaries, as our taxable income stems mostly from our operations located in China, which has a higher income tax rate than the U.S. In addition, during the first quarters of fiscal 2025 and 2024, we incurred pre-tax losses associated with our U.S. operations, for which an income tax benefit was not recorded due to the full valuation allowance applied against our U.S. net deferred income tax assets. The income tax charge associated with the full valuation allowance applied against our U.S. net deferred income tax assets was higher during the first quarter of fiscal 2025 compared with the first quarter of fiscal 2024, as our $(
During the first quarter of fiscal 2025, we incurred a greater consolidated pre-tax loss totaling $(
U.S. Valuation Allowance
We evaluate the realizability of our U.S. net deferred income tax assets to determine if a valuation allowance is required. We assess whether a valuation allowance should be established based on the consideration of all available evidence using a “more-likely-than-not” standard, with significant weight being given to evidence that can be objectively verified. Since the company operates in multiple jurisdictions, we assess the need for a valuation allowance on a jurisdiction-by-jurisdiction basis, considering the effects of local tax law.
As of July 28, 2024, we evaluated the realizability of our U.S. net deferred income tax assets to determine if a full valuation allowance was required. Based on our assessment, we determined we still have a recent history of significant cumulative U.S. pre-tax losses, in that we experienced U.S. pre-tax losses during each of the last three fiscal years from 2022 through 2024, and we are currently expecting significant U.S. pre-tax losses to continue during fiscal 2025. As a result of the significant weight of this
I-23
negative evidence, we believe it is more likely than not that our U.S. deferred income tax assets will not be fully realizable, and therefore we provided for a full valuation allowance against our U.S. net deferred income tax assets.
Based on our assessments as of July 28, 2024, July 30, 2023, and April 28, 2024, valuation allowances against our net deferred income tax assets pertain to the following:
(dollars in thousands) |
|
July 28, 2024 |
|
|
July 30, 2023 |
|
|
April 28, 2024 |
|
|||
U.S. federal and state net deferred income tax assets |
|
$ |
|
|
$ |
|
|
$ |
|
|||
U.S. capital loss carryforward |
|
|
|
|
|
|
|
|
|
|||
|
|
$ |
|
|
$ |
|
|
$ |
|
|||
Undistributed Earnings
We assess whether the undistributed earnings from our foreign subsidiaries will be reinvested indefinitely or eventually distributed to our U.S. parent company and whether we are required to record a deferred income tax liability for those undistributed earnings from foreign subsidiaries that will not be reinvested indefinitely. As of July 28, 2024, we assessed the liquidity requirements of our U.S. parent company and determined that our undistributed earnings and profits from our foreign subsidiaries would not be reinvested indefinitely and would eventually be distributed to our U.S. parent company. The conclusion reached from this assessment was consistent with prior reporting periods.
As a result of the 2017 Tax Cuts and Jobs Act, a U.S. corporation is allowed a
Uncertain Income Tax Positions
An unrecognized income tax benefit for an uncertain income tax position can be recognized in the first interim period if the more-likely-than-not recognition threshold is met by the end of the reporting period, or is effectively settled through examination, negotiation, or litigation, or the statute of limitations for the relevant taxing authority to examine and challenge the tax position has expired. If it is determined that any of the above conditions occur regarding our uncertain income tax positions, an adjustment to our unrecognized income tax benefit will be recorded at that time.
As of July 28, 2024, July 30, 2023, and April 28, 2024 we had a $
Our gross unrecognized income tax benefit of $
Income Taxes Paid
The following table sets forth taxes paid by jurisdiction:
|
|
Three Months |
|
|
Three Months |
|
||
|
|
Ended |
|
|
Ended |
|
||
|
|
July 28, |
|
|
July 30, |
|
||
(dollars in thousands) |
|
2024 |
|
|
2023 |
|
||
China Income Taxes, Net of Refunds |
|
|
|
|
|
|
||
Canada - Income Taxes, Net of Refunds |
|
|
— |
|
|
|
|
|
|
|
$ |
|
|
$ |
|
||
15. Stock-Based Compensation
Equity Incentive Plan Description
On September 16, 2015, our shareholders approved an equity incentive plan titled the Culp, Inc. 2015 Equity Incentive Plan (the “2015 Plan”). The 2015 Plan authorizes the grant of stock options intended to qualify as incentive stock options, nonqualified stock options, stock appreciation rights, restricted stock, restricted stock units, performance-based units, and other equity and cash related
I-24
awards as determined by the Compensation Committee of our board of directors. An aggregate of
As of July 28, 2024, there were
Performance-Based Restricted Stock Units
Senior Executives
We grant performance-based restricted stock units to senior executives which could earn up to a certain number of shares of common stock if certain performance targets are met over a three-fiscal year performance period as defined in the related restricted stock unit award agreements. The number of shares of common stock that are earned based on performance targets that have been achieved may be adjusted based on a market-based total shareholder return component as defined in the related restricted stock unit award agreements.
Our performance-based restricted stock units granted to senior executives were measured based on their fair market value on the date of grant. The fair market value per share was determined using the Monte Carlo simulation model for the market-based total shareholder return component and the closing price of our common stock for the performance-based component.
There were
Key Employees
We grant performance-based restricted stock units to key employees which could earn up to a certain number of shares of common stock if certain performance targets are met over a three-fiscal year performance period as defined in the related restricted stock unit award agreements. Our performance-based restricted stock units granted to key employees were measured based on the fair market value (the closing price of our common stock) on the date of grant. No market-based total shareholder return component was included in these awards.
There were
Overall
The following table summarizes information related to our grants of performance-based restricted stock units associated with senior executives and key employees that were unvested as of July 28, 2024:
|
|
(2) |
|
|
(3) |
|
|
|
|
|
|
|
|||
|
|
Performance-Based |
|
|
Restricted Stock |
|
|
|
|
|
|
|
|||
|
|
Restricted Stock |
|
|
Units Expected |
|
|
|
|
|
|
|
|||
Date of Grant |
|
Units Awarded |
|
|
to Vest |
|
|
Price Per Share |
|
|
|
Vesting Period |
|||
January 8, 2024 (1) |
|
|
|
|
|
|
|
$ |
|
(4) |
|
||||
September 28, 2023 (1) |
|
|
|
|
|
— |
|
|
$ |
|
(5) |
|
|||
August 10, 2022 (1) |
|
|
|
|
|
— |
|
|
$ |
|
(6) |
|
|||
I-25
There were
We recorded compensation expense of $
As of July 28, 2024, the remaining unrecognized compensation expense related to our performance-based restricted stock units was $
Time-Based Restricted Stock Units
The following table summarizes information related to our grants of time-based restricted stock unit awards associated with senior executives and key employees that were unvested as of July 28, 2024:
|
|
Time-Based |
|
|
|
|
|
|
|
||
|
|
Restricted Stock |
|
|
(1) |
|
|
|
|
||
Date of Grant |
|
Units Awarded |
|
|
Price Per Share |
|
Vesting Period |
||||
January 8, 2024 (2) |
|
|
|
|
$ |
|
|
|
|||
September 28, 2023 (2) |
|
|
|
|
$ |
|
|
|
|||
September 28, 2023 (3) |
|
|
|
|
$ |
|
|
|
|||
September 6, 2022 (2) |
|
|
|
|
$ |
|
|
|
|||
August 10, 2022 (2) |
|
|
|
|
$ |
|
|
|
|||
During the three-month period ending July 28, 2024, time-based restricted stock units totaling
We recorded compensation expense of $
As of July 28, 2024, the remaining unrecognized compensation expense related to our time-based restricted stock units was $
I-26
Immediately Vested Common Stock Awards
We granted a total of
We recorded $
16. Leases
Overview
We lease manufacturing facilities, showroom and office space, distribution centers, and equipment under operating lease arrangements. Our operating leases have remaining lease terms of to
Balance Sheet
The right of use assets and lease liabilities associated with our operating leases as of July 28, 2024, July 30, 2023, and April 28, 2024, are as follows:
|
|
|
|
|
|
|
|
|
|
|||
(dollars in thousands) |
|
July 28, |
|
|
July 30, |
|
|
April 28, |
|
|||
Right of use assets |
|
$ |
|
|
$ |
|
|
$ |
|
|||
Operating lease liability - current |
|
|
|
|
|
|
|
|
|
|||
Operating lease liability – noncurrent |
|
|
|
|
|
|
|
|
|
|||
Supplemental Cash Flow Information
|
|
Three Months |
|
|
Three Months |
|
||
(dollars in thousands) |
|
July 28, 2024 |
|
|
July 30, 2023 |
|
||
Operating lease liability payments |
|
$ |
|
|
$ |
|
||
Right of use assets exchanged for lease liabilities |
|
|
— |
|
|
|
— |
|
Operating lease expense for the three-month periods ended July 28, 2024, and July 30, 2023, was $
Other Information
Maturity of our operating lease liabilities for the remainder of fiscal 2025, the subsequent next four fiscal years, and thereafter follows:
(dollars in thousands) |
|
|
|
|
2025 |
|
|
|
|
2026 |
|
|
|
|
2027 |
|
|
|
|
2028 |
|
|
|
|
2029 |
|
|
|
|
Thereafter |
|
|
|
|
|
|
$ |
|
|
Less: interest |
|
|
( |
) |
Present value of lease liabilities |
|
$ |
|
|
As of July 28, 2024, the weighted average remaining lease term and discount rate for our operating leases follows:
|
|
July 28, 2024 |
|
|
Weighted average lease term (in years) |
|
|
||
Weighted average discount rate |
|
|
% |
|
I-27
17. Commitments and Contingencies
Litigation
The company is involved in legal proceedings and claims which have arisen in the ordinary course of business. Management has determined that it is not reasonably possible that these actions, when ultimately concluded and settled, will have a material adverse effect upon the consolidated financial position, consolidated results of operations, or consolidated cash flows of the company.
Accounts Payable – Capital Expenditures
As of July 28, 2024, July 30, 2023, and April 28, 2024, we had amounts due regarding capital expenditures totaling $
Purchase Commitments – Capital Expenditures
As of July 28, 2024, we had open purchase commitments to acquire equipment for our mattress fabrics segment totaling $
18. Statutory Reserves
Our subsidiary located in China was required to transfer
The transfer to this reserve must be made before distributions of any dividend to shareholders. As of July 28, 2024, the company’s statutory surplus reserve was $
The company’s subsidiary located in China can transfer funds to the parent company, except for the statutory surplus reserve of $
19. Common Stock Repurchase Program
In March 2020, our board of directors approved an authorization for us to acquire up to $
We did
As of July 28, 2024, $
I-28
CAUTIONARY STATEMENT CONCERNING FORWARD-LOOKING INFORMATION
This report contains “forward-looking statements” within the meaning of the federal securities laws, including the Private Securities Litigation Reform Act of 1995 (Section 27A of the Securities Act of 1933 and Section 21E of the Securities and Exchange Act of 1934). Such statements are inherently subject to risks and uncertainties that may cause actual events and results to differ materially from such statements. Forward-looking statements are statements that include projections, expectations, or beliefs about future events or results or otherwise are not statements of historical fact. Such statements are often but not always characterized by qualifying words such as “expect,” “believe,” “will,” “may,” “should,” “could,” “potential,” “continue,” “target,” “predict”, “seek,” “anticipate,” “estimate,” “intend,” “plan,” “project,” and their derivatives, and include but are not limited to statements about expectations, projections, or trends for our future operations, strategic initiatives and plans, restructuring actions, production levels, new product launches, sales, profit margins, profitability, operating (loss) income, capital expenditures, working capital levels, cost savings (including, without limitation, anticipated cost savings from restructuring actions), income taxes, SG&A or other expenses, pre-tax (loss) income, earnings, cash flow, and other performance or liquidity measures, as well as any statements regarding dividends, share repurchases, liquidity, use of cash and cash requirements, borrowing capacity, investments, potential acquisitions, restructuring and restructuring-related charges, expenses, and/or credits, future economic or industry trends, public health epidemics, or future developments. There can be no assurance that we will realize these expectations or meet our guidance, or that these beliefs will prove correct.
Factors that could influence the matters discussed in such statements include the level of housing starts and sales of existing homes, consumer confidence, trends in disposable income, and general economic conditions. Decreases in these economic indicators could have a negative effect on our business and prospects. Likewise, increases in interest rates, particularly home mortgage rates, and increases in consumer debt or the general rate of inflation, could affect us adversely. The future performance of our business depends in part on our success in conducting and finalizing acquisition negotiations and integrating acquired businesses into our existing operations. Changes in consumer tastes or preferences toward products not produced by us could erode demand for our products. Changes in tariffs or trade policy, including changes in U.S. trade enforcement priorities, or changes in the value of the U.S. dollar versus other currencies, could affect our financial results because a significant portion of our operations are located outside the United States. Strengthening of the U.S. dollar against other currencies could make our products less competitive on the basis of price in markets outside the United States, and strengthening of currencies in Canada and China can have a negative impact on our sales of products produced in those places. In addition, because our foreign operations use the U.S. dollar as their functional currency, changes in the exchange rate between the local currency of those operations and the U.S dollar can affect our reported profits from those foreign operations. Also, economic or political instability in international areas could affect our operations or sources of goods in those areas, as well as demand for our products in international markets. The impact of public health epidemics on employees, customers, suppliers, and the global economy, such as the recent coronavirus pandemic, could also adversely affect our operations and financial performance. In addition, the impact of potential asset impairments, including impairments of property, plant, and equipment, inventory, or intangible assets, as well as the impact of valuation allowances applied against our net deferred income tax assets, could affect our financial results. Increases in freight costs, labor costs, and raw material prices, including increases in market prices for petrochemical products, can also significantly affect the prices we pay for shipping, labor, and raw materials, respectively, and in turn, increase our operating costs and decrease our profitability. Also, our success in diversifying our supply chain with reliable partners to effectively service our global platform could affect our operations and adversely affect our financial results. Finally, the future performance of our business also depends on our ability to successfully restructure our mattress fabric operations and return the segment to profitability. Further information about these factors, as well as other factors that could affect our future operations or financial results and the matters discussed in forward-looking statements, is included in Item 1A “Risk Factors” in our most recent Form 10-K and Form 10-Q reports filed with the Securities and Exchange Commission.
Many of these factors are macroeconomic in nature and are, therefore, beyond our control. Should one or more of these risks or uncertainties materialize, or should underlying assumptions prove incorrect, our actual results, performance or achievements may vary materially from those described in this report as anticipated, believed, estimated, expected, intended, planned or projected. The forward-looking statements included in this report are made only as of the date of of this report. Unless required by United States federal securities laws, we neither intend nor assume any obligation to update these forward-looking statements for any reason after the date of this report to conform these statements to actual results or to changes in our expectations. A forward-looking statement is neither a prediction nor a guarantee of future events or circumstances, and those future events or circumstances may not occur. Additional risks and uncertainties that we do not presently know about or that we currently consider to be immaterial may also affect our business operations or financial results.
I-29
ITEM 2. MANAGEMENT’S DISCUSSION AND ANALYSIS OF FINANCIAL CONDITION AND RESULTS OF OPERATIONS
The following analysis of financial condition and results of operations should be read in conjunction with the consolidated financial statements and notes and other exhibits included elsewhere in this report.
General
Our fiscal year is the 52 or 53-week period ending on the Sunday closest to April 30. The three months ended July 28, 2024, and July 30, 2023, both represent 13-week periods.
Our operations are classified into two business segments: mattress fabrics and upholstery fabrics.
Mattress Fabrics
The mattress fabrics segment manufactures, sources, and sells fabrics and mattress covers primarily to bedding manufacturers. Currently, we have mattress fabric manufacturing operations located in Stokesdale, North Carolina, and Quebec, Canada. We also have a mattress cover operation located in Ouanaminthe, Haiti.
On April 29, 2024 (the first quarter of fiscal 2025), our board of directors made a decision to (1) consolidate the company's North American mattress fabrics operations, including a gradual discontinuation of operations and sale of the company's manufacturing facility located in Quebec, Canada; (2) move a portion of the knitting and finishing capacity from the company's manufacturing facility located in Quebec, Canada to the company's manufacturing facility located in Stokesdale, North Carolina; (3) transition the mattress fabrics segment's weaving operation to a strategic sourcing model through the company's long standing supply partners; and (4) consolidate the company's sewn mattress cover operation located in Ouanaminthe, Haiti, from two leased facilities into one building and reduce other operating expenses at this location. See Note 9 of the consolidated financial statements for further details regarding our restructuring activities.
Upholstery Fabrics
The upholstery fabrics segment develops, sources, manufactures, and sells fabrics primarily to residential, commercial, and hospitality furniture manufacturers. We have upholstery fabric operations located in Shanghai, China, and Burlington, North Carolina. During the fourth quarter of fiscal 2024, we established a wholly-owned subsidiary, Culp Fabrics Vietnam Limited, with an administrative office located in Ho Chi Minh City, Vietnam, for the purpose of enhancing our strategic sourcing opportunities and to further diversify our supply chain in Asia.
Additionally, Read Window Products, LLC (“Read”), a wholly-owned subsidiary with operations located in Knoxville, Tennessee, and Burlington, North Carolina (within an existing upholstery fabrics facility), provides window treatments and sourcing of upholstery fabrics and other products, as well as measuring and installation services for Read’s products, to customers in the hospitality and commercial industries. Read also supplies soft goods such as decorative top sheets, coverlets, duvet covers, bed skirts, bolsters, and pillows.
Executive Summary
We evaluate the operating performance of our business segments based upon (loss) income from operations before certain unallocated corporate expenses and other items that are not expected to occur on a regular basis. Cost of sales for each business segment includes costs to develop, manufacture, or source our products, including costs such as raw material and finished good purchases, direct and indirect labor, overhead, and incoming freight charges. Unallocated corporate expenses primarily represent compensation and benefits for certain executive officers and their support staff, all costs associated with being a public company, amortization of intangible assets, and other miscellaneous expenses.
I-30
Results of Operations
|
|
Three Months Ended |
|
|
||||
(dollars in thousands) |
|
July 28, |
|
July 30, |
|
Change |
||
Net sales |
|
$ |
56,537 |
|
$ |
56,662 |
|
(0.2)% |
Gross profit |
|
|
5,076 |
|
|
7,085 |
|
(28.4)% |
Gross margin |
|
|
9.0 |
% |
|
12.5 |
% |
(350)bp |
Selling, general, and administrative expenses |
|
|
9,296 |
|
|
9,829 |
|
(5.4)% |
Restructuring expense |
|
|
2,631 |
|
|
338 |
|
678.4% |
Loss from operations |
|
|
(6,851 |
) |
|
(3,082 |
) |
122.3% |
Operating margin |
|
|
(12.1 |
)% |
|
(5.4 |
)% |
(670)bp |
Loss before income taxes |
|
|
(7,021 |
) |
|
(2,641 |
) |
165.8% |
Income tax expense |
|
|
240 |
|
|
701 |
|
(65.8)% |
Net loss |
|
|
(7,261 |
) |
|
(3,342 |
) |
117.3% |
Net Sales
Overall, our consolidated net sales for the first quarter of fiscal 2025 were flat compared with the same period a year ago, with mattress fabrics sales decreasing 3.9% and upholstery fabrics sales increasing 3.7%.
The decrease in net sales for our mattress fabrics segment, as compared to the prior-year period, reflects reduced demand as a result of weakness in the domestic mattress industry. The increase in net sales for our upholstery fabrics segment reflects improved demand for our residential and hospitality/commercial upholstery fabric products as compared to the prior-year period.
See the Segment Analysis section below for further details.
Loss Before Income Taxes
Overall, our loss before income taxes for the first quarter of fiscal 2025 was $(7.0) million, compared with loss before income taxes of $(2.6) million for the prior-year period.
Operating performance for the first quarter of fiscal 2025, as compared to the prior-year period, was negatively affected by manufacturing inefficiencies primarily related to the significant restructuring activity underway in the mattress fabrics segment, along with $2.7 million in restructuring and restructuring-related charges during the period (compared with $517,000 in restructuring and restructuring-related charges during the prior-year period). These factors were partially offset by improved operating performance from our upholstery fabrics segment, as well as lower SG&A expenses.
See the Segment Analysis section below for further details.
Income Taxes
We recorded income tax expense of $240,000, or (3.4%) of loss before income taxes, for the three-month period ended July 28, 2024, compared with income tax expense of $701,000, or (26.5%) of loss before income taxes, for the three-month period ended July 30, 2023.
Our consolidated effective income tax rates during the first quarter of fiscal 2025 and fiscal 2024 were both adversely affected by the mix of earnings between our U.S. operations and foreign subsidiaries, as our taxable income stems mostly from our operations located in China, which has a higher income tax rate than the U.S. In addition, during the first quarters of fiscal 2025 and fiscal 2024, we incurred pre-tax losses associated with our U.S. operations, for which an income tax benefit was not recorded due to the full valuation allowance applied against our U.S. net deferred income tax assets. The income tax charge associated with the full valuation allowance applied against our U.S. net deferred income tax assets was higher during the first quarter of fiscal 2025 as compared with the first quarter of fiscal 2024, as our $(7.0) million U.S. pre-tax loss incurred during the first quarter of fiscal 2025 was significantly greater than the $(3.3) million U.S. pre-tax loss incurred during the first quarter of fiscal 2024.
During the first quarter of fiscal 2025, we incurred a greater consolidated pre-tax loss totaling $(7.0) million, compared with $(2.6) million during the first quarter of fiscal 2024. As a result, the principal differences between income tax expense at the U.S. federal income tax rate and the effective income tax rate reflected in the consolidated financial statements were more pronounced during the first quarter of fiscal 2024, as compared with the first quarter of fiscal 2025.
Refer to Note 14 of the consolidated financial statements for further details regarding our provision for income taxes.
I-31
Liquidity
As of July 28, 2024, our cash and cash equivalents (collectively, “cash”) totaled $13.5 million, an increase of $3.5 million compared with cash of $10.0 million as of April 28, 2024. This increase was mostly due to $4.0 million in cash proceeds from borrowings on our line of credit associated with our operations located in China, partially offset by capital expenditures totaling $501,000.
Our net cash used in operating activities was $206,000 during the first quarter of fiscal 2025, a decrease of $4.2 million compared with net cash used in operating activities of $4.4 million during the first quarter of fiscal 2024. This trend mostly reflects (i) a decrease in accounts payable and accrued expenses during the first quarter of fiscal 2024 due to a decline in net sales for the first quarter of fiscal 2024 as compared with the first quarter of fiscal 2023, which decline did not recur during the first quarter of fiscal 2025 as compared with the first quarter of fiscal 2024; (ii) a decrease in inventory due to improved inventory management for both the mattress fabrics and upholstery fabrics segments and due to the gradual wind down of operations at the company's manufacturing facility in Quebec, Canada, as described below in the section below titled “—Segment Analysis — Mattress Fabrics Segment — Restructuring Activities” of this Item 2 – MANAGEMENT’S DISCUSSION AND ANALYSIS OF FINANCIAL CONDITION ; and (iii) a decrease in accounts receivable during the first quarter of fiscal 2024 due to a decline in net sales during the first quarter of fiscal 2024 as compared with the first quarter of fiscal 2023, which decline did not recur during the first quarter of fiscal 2025 as compared with the first quarter of fiscal 2024.
As of July 28, 2024, we had outstanding borrowings totaling $4.0 million under a line of credit agreement associated with our operations located in China.
Segment Analysis
Mattress Fabrics Segment
|
|
Three Months Ended |
|
|
||||
(dollars in thousands) |
|
July 28, |
|
July 30, |
|
Change |
||
Net sales |
|
$ |
28,076 |
|
$ |
29,222 |
|
(3.9)% |
Gross (loss) profit |
|
|
(326 |
) |
|
1,994 |
|
(116.3)% |
Gross profit margin |
|
|
(1.2 |
)% |
|
6.8 |
% |
(800)bp |
Selling, general, and administrative expenses |
|
|
3,223 |
|
|
3,393 |
|
(5.0)% |
Restructuring expense |
|
|
2,499 |
|
|
— |
|
100.0% |
Loss from operations |
|
|
(3,549 |
) |
|
(1,398 |
) |
153.9% |
Operating margin |
|
|
(12.6 |
)% |
|
(4.8 |
)% |
(780)bp |
|
|
|
|
|
|
|
||
Net Sales
Mattress fabrics sales decreased 3.9% during the first quarter of fiscal 2025 compared to the prior-year period.
This decrease in net sales for our mattress fabrics segment reflects reduced demand due to weakness in the domestic mattress industry, driven by a challenging macroeconomic environment that has affected consumer discretionary spending and housing markets.
Based on demand trends and ongoing macroeconomic challenges, we took aggressive action during the first quarter of fiscal 2025 to bring our manufacturing costs and capacity in line with current and expected demand. We announced a major restructuring plan primarily focused on the mattress fabrics segment early in the quarter, and we are making steady progress on the execution of this restructuring plan, which is expected to be mostly completed by the end of this calendar year. See “—Restructuring Activities” below for further details.
Looking ahead, we are diligently focused on winning new placements to increase revenue and margins. However, with no ascertainable catalysts that might be expected to drive recovery in the near term, we expect the current macroeconomic environment will continue to pressure consumer spending and housing market trends (and our net sales) for some time. In the face of these macro headwinds, we are working to manage the aspects of our business we can control, including the execution of our restructuring plan. We believe the strategic actions we are taking will position us for profitable growth opportunities, but greater macro-industry and end-consumer support will be needed to drive recovery in the mattress industry and support our future sales growth. Additionally, the potential ongoing geopolitical disruptions related to wars in Ukraine and the Middle East remain unknown and depend on factors beyond our knowledge or control. These situations could cause disruption to global markets that could adversely affect our operations and financial performance.
I-32
Gross Profit, Selling, General & Administrative Expenses, and Loss from Operations
Loss from operations was $3.5 million for the first quarter of fiscal 2025, compared to loss from operations of $1.4 million for the first quarter of fiscal 2024.
Operating performance for the first quarter of fiscal 2025, as compared to the prior-year period, was pressured by lower sales volumes and manufacturing inefficiencies primarily related to our significant restructuring initiatives to gradually wind down our Canadian operation and move certain knitting equipment to our Stokesdale, North Carolina, manufacturing facility. These factors were partially offset by lower SG&A expense for the quarter.
We expect manufacturing inefficiencies related our restructuring initiatives, as well as ongoing industry softness affecting sales volumes, will affect profitability through at least the second quarter of fiscal 2025, as we work to implement our restructuring plan to align capacity with current and expected demand. However, we expect these restructuring initiatives, once fully implemented, will enable the mattress fabrics segment to grow more efficiently and profitably with a lower level of fixed costs, even at currently depressed sales levels. See “—Restructuring Activities” below for further details. Importantly, these strategic steps do not limit our ability to grow the mattress fabrics business, but instead allow us to better optimize our global mix of manufacturing capabilities and long-term sourcing partners. We will also consider further adjustments to right-size and restructure our operations as necessary to align with current demand levels, as well as additional reasonable pricing actions as competitive conditions permit to further mitigate and manage inflation.
Restructuring Activities
On April 29, 2024 (first quarter of fiscal 2025), our board of directors made a decision to (1) consolidate the company's North American mattress fabrics operations, including a gradual discontinuation of operations and sale of the company's manufacturing facility located in Quebec, Canada; (2) move a portion of the knitting and finishing capacity from the company's manufacturing facility located in Quebec, Canada to the company's manufacturing facility located in Stokesdale, North Carolina; (3) transition the mattress fabrics segment's weaving operation to a strategic sourcing model through the company's long standing supply partners; and (4) consolidate the company's two leased facilities related to the sewn mattress cover operation into one facility located in Ouanaminthe, Haiti, and reduce other operating expenses at this location.
We expect the gradual discontinuance of operations and the closure of the facility located in Quebec, Canada, will be completed by December 31, 2024. The consolidation activity associated with the sewn mattress cover operation located in Haiti was completed during the first quarter of fiscal 2025. These actions are expected to result in restructuring and restructuring related charges of approximately $5.0 million during fiscal 2025, of which approximately $2.9 million is expected to be cash expenditures.
The $5.0 million of estimated restructuring and restructuring related charges associated with our mattress fabrics segment represents (i) other associated costs of $1.7 million mostly related to relocating equipment from our facility in Quebec, Canada, to our facility in Stokesdale, North Carolina; (ii) additional depreciation expense of $1.4 million related to the shortening of useful lives of equipment resulting from the gradual discontinuation of our Canadian operations; (iii) employee termination benefits of $1.2 million; (iv) lease termination costs of $531,000; (v) writedowns and other inventory related adjustments of $116,000; and (vi) impairment charges and losses on the disposal of equipment totaling $95,000. These restructuring and restructuring related charges exclude any expected gain on the sale of real estate associated with the closure of the Canadian facility, the amount of which is currently undetermined but which will ultimately reduce the amount of the restructuring charges incurred. Based on management's internal analysis we expect cash proceeds from the sale of real estate (net of all taxes and commissions) to exceed the amount of restructuring charges incurred.
Based on changes in business and current industry economic conditions, it is possible that the above estimates provided by management to determine restructuring and restructuring related charges incurred during fiscal 2025, and proceeds generated from the sale of the manufacturing facility located in Quebec, Canada, could be materially different from our actual results, and therefore could adversely affect the success of this restructuring plan.
I-33
The following summarizes the restructuring and restructuring related charges for the mattress fabrics segment for the three-month period ending July 28, 2024:
|
|
Three Months Ended |
|
|
(dollars in thousands) |
|
July 28, 2024 |
|
|
Additional depreciation expense for shortened useful lives of equipment |
|
$ |
875 |
|
Employee termination benefits |
|
|
587 |
|
Lease termination costs |
|
|
670 |
|
Other Associated Costs |
|
|
272 |
|
Loss on disposal and markdowns of inventory |
|
|
116 |
|
Impairment and loss on disposal of equipment |
|
|
95 |
|
Restructuring expense and restructuring related charges (1) |
|
$ |
2,615 |
|
(1) Of the total $2.6 million restructuring and restructuring related charges, $2.5 million and $116,000 were classified within restructuring expense and cost of sales, respectively, in the Consolidated Statement of Net Loss for the three-month period ending July 28, 2024.
Refer to Note 9 of the the consolidated financial statements for further details.
Segment assets
Segment assets consist of accounts receivable, inventory, property, plant, and equipment, right of use assets, and assets held for sale:
(dollars in thousands) |
|
July 28, 2024 |
|
July 30, 2023 |
|
April 28, 2024 |
|
|||
Accounts receivable |
|
$ |
10,094 |
|
$ |
11,058 |
|
$ |
10,003 |
|
Inventory |
|
|
25,278 |
|
|
24,579 |
|
|
27,671 |
|
Property, plant & equipment |
|
|
28,844 |
|
|
32,792 |
|
|
31,472 |
|
Right of use assets |
|
|
568 |
|
|
2,139 |
|
|
1,627 |
|
Assets held for sale |
|
|
607 |
|
|
— |
|
|
— |
|
|
|
$ |
65,391 |
|
$ |
70,568 |
|
$ |
70,773 |
|
|
|
|
|
|
|
|
|
|||
Refer to Note 13 of the consolidated financial statements for disclosures regarding determination of our segment assets.
Accounts Receivable
As of July 28, 2024, accounts receivable decreased by $964,000, or 8.7%, compared with July 30, 2023. This reflects the decrease in net sales noted above and faster cash collections from a significant customer who utilized more cash discounts during the first quarter of fiscal 2025, as compared with the first quarter of fiscal 2024. Accordingly, days’ sales outstanding decreased to 33 days for the first quarter of fiscal 2025, as compared to 34 days for the first quarter of fiscal 2024.
As of July 28, 2024, accounts receivable remained flat compared with April 28, 2024. This primarily reflects an increase in net sales for the first quarter of fiscal 2025, as compared to the fourth quarter of fiscal 2024, offset by faster cash collections, as we experienced faster cash collections from a significant customer who utilized more cash discounts during the first quarter of fiscal 2025, as compared with the first quarter of fiscal 2024. Net sales for the first quarter of fiscal 2025 were $28.1 million, an increase of 9.0% compared with net sales of $25.8 million during the fourth quarter of fiscal 2024. As a result, days’ sales outstanding decreased to 33 days for the first quarter of fiscal 2025, as compared to 35 days for the fourth quarter of fiscal 2024.
Inventory
As of July 28, 2024, inventory modestly increased by $699,000, or 2.8%, compared with July 30, 2023. In connection with the restructuring activity described above in “—Restructuring Activities,” this trend represents an increase in finished goods inventory to accommodate customers while the weaving operation is transitioned to a strategic sourcing model and knitting and finishing capacity is relocated from the manufacturing facility in Quebec, Canada, to our facility in Stokesdale, North Carolina. This increase in finished goods inventory was partially offset by lower raw material purchases related to the gradual discontinuation of operations of the company's manufacturing facility located in Quebec, Canada, as described above in “—Restructuring Activities,” and also by the decrease in net sales described above.
As of July 28, 2024, inventory decreased by $2.4 million, or 8.6%, compared with April 28, 2024. This decrease stems from the gradual discontinuation of operations of the company's manufacturing facility located in Quebec, Canada, as described above in
I-34
“—Restructuring Activities,” and from improved inventory management during the first quarter of fiscal 2025 as compared with the fourth quarter of fiscal 2024, taking into account current and expected future demand trends.
Inventory turns were 4.3 for the first quarter of fiscal 2025, as compared with 4.4 for the first quarter of fiscal 2024 and 3.6 for the fourth quarter of fiscal 2024.
Property, Plant, & Equipment
During fiscal 2024 and continuing through the first quarter of fiscal 2025, property, plant, and equipment has steadily decreased due to reduced capital spending stemming from current unfavorable macro-economic conditions within the home furnishings and bedding industries, as well as the actions taken as described above in “—Restructuring Activities.”
The $28.8 million as of July 28, 2024, represents property, plant, and equipment of $20.9 million, $7.4 million, and $511,000 located in the U.S., Canada, and Haiti, respectively. The $32.8 million as of July 30, 2023, represents property, plant, and equipment of $22.1 million, $10.1 million, and $594,000 located in the U.S., Canada, and Haiti, respectively. The $31.5 million as of April 28, 2024, represents property, plant, and equipment of $21.5 million, $9.4 million, and $555,000 located in the U.S., Canada, and Haiti, respectively.
Right of Use Assets
During fiscal 2024 and continuing through the first quarter of fiscal 2025, right of use assets have steadily decreased due to rent expense incurred over the terms of the existing lease agreements. In addition, in connection with the restructuring activity described above in “—Restructuring Activities,” right of use assets (i) decreased due to the termination of an agreement to lease a facility located in Ouanaminthe, Haiti, and (ii) shortened the period of use associated with two leased facilities located in Quebec, Canada.
The $568,000 as of July 28, 2024, represents right of use assets of $350,000 and $218,000 located in Haiti and Canada, respectively. The $2.1 million as of July 30, 2023, represents right of use assets of $1.4 million and $720,000 located in Haiti, and Canada, respectively. The $1.6 million as of April 28, 2024, represents right of use assets of $1.1 million and $545,000 located in Haiti and Canada, respectively.
Assets Held for Sale
As of July 28, 2024, and in connection with actions described above in “—Restructuring Activities,” we classified certain equipment located at our mattress fabric facility in Quebec, Canada, totaling $357,000 and a right of use asset of $250,000 located at our sewn mattress cover facility located in Ouanaminthe, Haiti, as held for sale. Refer to Note 9 of the the consolidated financial statements for further details.
Upholstery Fabrics Segment
Net Sales
|
|
Three Months Ended |
|
|
|
|||||||||
(dollars in thousands) |
|
July 28, |
|
July 30, |
|
% Change |
|
|||||||
Non-U.S. Produced |
|
$ |
25,337 |
|
89% |
|
$ |
24,633 |
|
90% |
|
|
2.9 |
% |
U.S. Produced |
|
|
3,124 |
|
11% |
|
|
2,807 |
|
10% |
|
|
11.3 |
% |
Total |
|
$ |
28,461 |
|
100% |
|
$ |
27,440 |
|
100% |
|
|
3.7 |
% |
Upholstery fabrics sales increased 3.7% in the first quarter of fiscal 2025 compared to the prior-year period.
This increase in net sales for our upholstery fabrics segment reflects improved demand for our residential upholstery fabrics business and our hospitality/commercial business as compared to the prior-year period, although overall industry weakness continues to affect the residential home furnishings industry.
Looking ahead, we expect the soft industry demand backdrop for residential home furnishings may affect our residential business for some period of time. Despite this challenge, we believe our business is well positioned for the long term with our product-driven strategy and innovative product offerings, including our popular portfolio of LiveSmart® performance products, supported by our flexible Asian platform and our long-term supplier relationships. We also believe overall demand remains solid for our hospitality/commercial business.
I-35
Notably, the potential ongoing geopolitical disruptions related to wars in Ukraine and the Middle East remain unknown and depend on factors beyond our control. At this time, we cannot reasonably estimate the impact on our upholstery fabrics segment, but we note that if conditions worsen in these situations, including shipping disruptions related to wars in the Middle East, the impact on our operations, and/or on our suppliers, customers, consumers, and the global economy, could adversely affect our financial performance.
Gross Profit, Selling, General & Administrative Expenses, and Income from Operations
|
|
Three Months Ended |
|
|
|
|||||
(dollars in thousands) |
|
July 28, |
|
|
July 30, |
|
|
Change |
||
Gross profit |
|
|
5,518 |
|
|
|
5,270 |
|
|
4.7% |
Gross margin |
|
|
19.4 |
% |
|
|
19.2 |
% |
|
20bp |
Selling, general, and administrative expenses |
|
|
3,806 |
|
|
|
3,941 |
|
|
(3.4)% |
Restructuring expense |
|
|
132 |
|
|
|
338 |
|
|
(60.9)% |
Income from operations |
|
|
1,712 |
|
|
|
1,328 |
|
|
28.9% |
Operating margin |
|
|
6.0 |
% |
|
|
4.8 |
% |
|
120bp |
|
|
|
|
|
|
|
|
|
||
Income from operations was $1.7 million for the first quarter of fiscal 2025, compared to income from operations of $1.3 million for the first quarter of fiscal 2024.
The increase in upholstery fabrics profitability for the first quarter of fiscal 2025, as compared to the prior-year period, primarily reflects higher sales, lower fixed costs, and lower SG&A expense, offset somewhat by higher freight costs during the period.
Based on market dynamics, we took action during the fourth quarter of fiscal 2024 to restructure our upholstery fabrics finishing operation in China to align with current demand and further leverage our strategic supply relationships. We completed this restructuring initiative during the first quarter of fiscal 2025 (see “—Restructuring Activities—Shanghai, China—Upholstery Fabrics Finishing Operation” below). We believe this move will allow us to reduce our operating costs while maintaining our ability to support our customers.
Looking ahead, the residential home furnishings industry remains under pressure due to shifting consumer spending trends, inflation, reduced home sales, and other macroeconomic conditions affecting discretionary consumer spending. As a result, we expect lower sales volumes in our residential business may affect our profitability until market conditions improve. However, for fiscal 2025, we expect to benefit from continued solid demand in our hospitality/commercial fabrics business; improvement in our Read business; and fixed cost savings from our strategic decision to rationalize our upholstery fabric finishing operation in China and further leverage our long-term supply relationships. We will also continue our ongoing cost reduction efforts and will consider further adjustments to rationalize our operations as necessary to align with current demand levels, while maintaining our ability to service our customers.
Restructuring Activities
Shanghai, China
Upholstery Fabrics Finishing Operation
During the fourth quarter of fiscal 2024, we rationalized our upholstery fabrics finishing operation in Shanghai, China, to align with current demand trends and further leverage our strategic supply relationships to meet customer finishing needs. This restructuring activity was completed during the first quarter of fiscal 2025 and resulted in cumulative restructuring and restructuring related charges totaling $218,000.
Ouanaminthe, Haiti
Cut and Sew Upholstery Fabrics Operation
During the third quarter of fiscal 2023, Culp Upholstery Fabrics Haiti, Ltd. ("CUF Haiti") entered into an agreement to terminate a lease associated with a facility, and in turn moved the production of upholstery cut and sewn kits to an existing facility leased by Culp Home Fashions Haiti, Ltd. ("CHF Haiti") during the fourth quarter of fiscal 2023. Both CUF Haiti and CHF Haiti are
I-36
indirectly wholly-owned subsidiaries of the company. During the first quarter of fiscal 2024, demand for upholstery cut and sewn kits declined more than previously anticipated, resulting in the strategic action to discontinue the production of upholstery cut and sew kits in Haiti. This restructuring activity was completed during the third quarter of fiscal 2024 and resulted in a cumulative restructuring and restructuring related charges of $1.3 million.
The following summarizes our restructuring expense and restructuring related charges for all restructuring activities for the upholstery fabrics segment for the three- months ending July 28, 2024, and July 30, 2023:
|
(1) |
|
|
(2) |
|
||
|
Three Months Ended |
|
|
Three Months Ended |
|
||
(dollars in thousands) |
July 28, 2024 |
|
|
July 30, 2023 |
|
||
Employee termination benefits |
$ |
102 |
|
|
$ |
101 |
|
Impairment loss and disposal of equipment |
|
— |
|
|
|
237 |
|
Loss on disposal and markdowns of inventory |
|
— |
|
|
|
179 |
|
Other associated costs |
|
30 |
|
|
|
— |
|
Restructuring expense and restructuring related charges (3) (4) |
$ |
132 |
|
|
$ |
517 |
|
(1) Of the $132,000 total, $118,000 affected our U.S. upholstery fabrics operations and related to cost reductions under the Fiscal 2025 Restructuring Plan, which is described in Note 9 of the consolidated financial statements. In addition, the $132,000 includes $14,000 related to the rationalization of our upholstery fabrics finishing operation located in Shanghai, China, as described above.
(2) The total $517,000 related to the closure of our upholstery cut and sewn kits operation located in Ouanaminthe, Haiti, as described above.
(3) The total $132,000 was recorded within restructuring expense in the Consolidated Statement of Net Loss for the three-month period ending July 28, 2024.
(4) Of the $517,000 total, $338,000 and $179,000 was recorded within restructuring expense and cost of sales, respectively, in the Consolidated Statement of Net Loss for the three-month period ending July 30, 2023.
Segment Assets
Segment assets consist of accounts receivable, inventory, property, plant, and equipment, and right of use assets:
(dollars in thousands) |
|
July 28, 2024 |
|
|
July 30, 2023 |
|
|
April 28, 2024 |
|
|||
Accounts receivable |
|
$ |
11,493 |
|
|
$ |
11,554 |
|
|
$ |
11,135 |
|
Inventory |
|
|
16,390 |
|
|
|
19,238 |
|
|
|
17,172 |
|
Property, plant & equipment |
|
|
1,098 |
|
|
|
1,491 |
|
|
|
1,125 |
|
Right of use assets |
|
|
1,478 |
|
|
|
2,237 |
|
|
|
1,952 |
|
|
|
$ |
30,459 |
|
|
$ |
34,520 |
|
|
$ |
31,384 |
|
|
|
|
|
|
|
|
|
|
|
|||
Refer to Note 13 of the consolidated financial statements for disclosures regarding determination of our segment assets.
Accounts Receivable
As of July 28, 2024, accounts receivable remained flat as compared with July 30, 2023. This reflects a 3.7% increase in net sales for the first quarter of fiscal 2025, as compared with the prior-year period, offset by faster cash collections from a significant customer who utilized more cash discounts during the first quarter of fiscal 2025, as compared with the prior-year period. As a result, days’ sales outstanding for this segment decreased to 32 days for the first quarter of fiscal 2025, compared with 35 days for the first quarter of fiscal 2024.
As of July 28, 2024, accounts receivable remained flat compared with April 28, 2024. This reflects a significant increase in net sales during the first quarter of fiscal 2025, as compared with the fourth quarter of fiscal 2024. Net sales for the first quarter of fiscal 2025 were $28.5 million, an increase of $4.7 million, or 19.7%, compared with net sales of $23.8 million for the fourth quarter of fiscal 2024. However, this increase was offset by faster cash collections from a significant customers during the first quarter of fiscal 2025, as compared with the fourth quarter of fiscal 2024. As a result, days’ sales outstanding for this segment decreased to 32 days for the first quarter of fiscal 2025, compared with 37 days for the fourth quarter of fiscal 2024.
I-37
Inventory
As of July 28, 2024, inventory decreased by $2.8 million, or 14.8%, compared with July 30, 2023. Although this segment's net sales increased during the first quarter of fiscal 2025, as compared with the prior-year period (as described above), this decrease in inventory reflects management's ability to maintain an appropriate level of inventory, taking into account current and expected future demand trends and any changes in our global supply chain.
As of July 28, 2024, inventory decreased by $782,000, or 4.6%, compared with April 28, 2024. Although this segment's net sales significantly increased during the first quarter of fiscal 2025, as compared with the fourth quarter of fiscal 2024, this decrease in inventory reflects management's ability to maintain an appropriate level of inventory, taking into account current and expected future demand trends and any changes in our global supply chain. Net sales for the first quarter of fiscal 2025 were $28.5 million, an increase of $4.7 million, or 19.7%, compared with net sales of $23.8 million for the fourth quarter of fiscal 2024.
Inventory turns were 5.3 for the first quarter of fiscal 2025, compared with 4.4 for the first quarter of fiscal 2024 and 4.4 for the fourth quarter of fiscal 2024.
Property, Plant, & Equipment
As of July 28, 2024, property, plant, and equipment steadily decreased compared with July 30, 2023, and April 28, 2024, due to a reduction in capital spending as a result of current unfavorable macro-economic conditions within the home furnishings industry.
The $1.1 million as of July 28, 2024, represents property, plant, and equipment of $990,000 and $108,000 located in the U.S., and China, respectively. The $1.5 million as of July 30, 2023, represents property, plant, and equipment of $1.0 million, $327,000, and $159,000 located in the U.S., Haiti, and China, respectively. The $1.1 million as of April 28, 2024, represents property, plant, and equipment of $1.0 million and $120,000 located in the U.S., and China, respectively.
Right of Use Assets
As of July 28, 2024, right of use assets steadily decreased compared with July 30, 2023, and April 28, 2024. This decrease mostly resulted from rent expense incurred over the terms of the existing respective lease agreements and the termination of our agreement to lease a building associated with our upholstery fabrics finishing operation located in Shanghai, China.
The $1.5 million as of July 28, 2024, represents right of use assets of $1.1 million and $393,000 located in the U.S., and China, respectively. The $2.2 million as of July 30, 2023, represents right of use assets of $1.2 million and $977,000 located in China and the U.S., respectively. The $2.0 million as of April 28, 2023, represents right of use assets of $1.3 million and $709,000 located in China and the U.S., respectively.
Other Income Statement Categories
|
|
Three Months Ended |
|
|
|
|
||||||
(dollars in thousands) |
|
July 28, 2024 |
|
|
July 30, 2023 |
|
|
% Change |
|
|||
SG&A expenses |
|
$ |
9,296 |
|
|
$ |
9,829 |
|
|
|
(5.4 |
)% |
Interest income |
|
|
262 |
|
|
|
345 |
|
|
|
(24.1 |
)% |
Other expense (income) |
|
|
(404 |
) |
|
|
96 |
|
|
|
(520.8 |
)% |
|
|
|
|
|
|
|
|
|
|
|||
Selling, General, and Administrative Expenses ("SG&A")
The decrease in selling, general, and administrative expenses during the first quarter of fiscal 2025, as compared with the first quarter of fiscal 2024, relates to a variety of items including: (i) lower stock-based compensation expense reflecting less favorable financial results in relation to pre-established targets; (ii) lower professional and consulting fees; and (iii) a decrease in customer samples expense.
Interest Income
The decrease in interest income is due to a lower average cash balance during the first quarter of fiscal 2025, as compared with the first quarter of fiscal 2024.
Other (Expense) Income
I-38
Management is required to assess certain economic factors to determine the currency of the primary economic environment in which our foreign subsidiaries operate. Based on our assessments, the U.S. dollar was determined to be the functional currency of our operations located in China, Canada, and Vietnam.
The change in other expense during the first quarter of fiscal 2025, as compared with other income during the first quarter of fiscal 2024, is due mostly to less favorable foreign currency exchange rates applied against our balance sheet accounts denominated in Chinese Renminbi to determine the corresponding U.S. dollar financial reporting amounts during the first quarter of fiscal 2025, as compared with the first quarter of fiscal 2024. During the first quarter of fiscal 2025, we reported a foreign currency exchange loss associated with our operations located in China totaling $46,000 compared with a foreign currency exchange gain of $451,000 during the first quarter of fiscal 2024.
The $46,000 foreign currency exchange loss related to our operations in China was mostly non-cash and was partially offset by $(37,000) of income tax benefit, which will decrease our income tax payments and withholding tax payments associated with future earnings and profits repatriated from our operations located in China to the company's U.S. parent. The income tax benefit of $(37,000) was associated with taxable foreign currency exchange losses based on less favorable foreign currency exchange rates applied against balance sheet accounts denominated in U.S. dollars to determine the corresponding Chinese Renminbi local currency amounts. The foreign currency exchange rate gains (losses) related to our U.S. dollar denominated balance sheet accounts associated with our operations located in China are considered taxable income or tax deductible, as we incur income tax expense (benefit) and pay income taxes in China's local currency.
Income Taxes
Effective Income Tax Rate & Income Tax Expense
We recorded income tax expense of $240,000, or (3.4%) of loss before income taxes, for the three-month period ending July 28, 2024, compared with income tax expense of $701,000, or (26.5%) of loss before income taxes, for the three-month period ending July 30, 2023.
Our effective income tax rates for the three-month periods ended July 28, 2024, and July 30, 2023, were based upon the estimated effective income tax rate applicable for the full year after giving effect to any significant items related specifically to interim periods. When calculating the annual estimated effective income tax rates for the three-month periods ended July 28, 2024, and July 30, 2023, we were subject to loss limitation rules. These loss limitation rules require any taxable loss associated with our U.S. or foreign operations to be excluded from the annual estimated effective income tax rate calculation if it was determined that no income tax benefit could be recognized during the current fiscal year. The effective income tax rate can be affected over the fiscal year by the mix and timing of actual earnings from our U.S. operations and foreign subsidiaries located in China, Canada, Haiti, and Vietnam versus annual projections, as well as changes in foreign currency exchange rates in relation to the U.S. dollar.
The following schedule summarizes the principal differences between income tax expense at the U.S. federal income tax rate and the effective income tax rate reflected in the consolidated financial statements for the three-month periods ending July 28, 2024, and July 30, 2023:
|
|
July 28, |
|
|
July 30, |
|
||
|
|
2024 |
|
|
2023 |
|
||
U.S. federal income tax rate |
|
|
21.0 |
% |
|
|
21.0 |
% |
U.S. valuation allowance |
|
|
(23.5 |
) |
|
|
(34.1 |
) |
Withholding taxes associated with foreign jurisdictions |
|
|
(1.0 |
) |
|
|
(9.7 |
) |
Foreign income tax rate differential |
|
|
0.7 |
|
|
|
(6.0 |
) |
Stock-based compensation |
|
|
(0.9 |
) |
|
|
— |
|
Tax effects of local currency foreign exchange gains |
|
|
(0.4 |
) |
|
|
2.3 |
|
Uncertain income tax positions |
|
|
1.2 |
|
|
|
(0.1 |
) |
Other |
|
|
(0.5 |
) |
|
|
0.1 |
|
|
|
(3.4)% |
|
|
(26.5)% |
|
||
Our consolidated effective income tax rates during the first quarter of fiscal 2025 and the first quarter of fiscal 2024 were both adversely affected by the mix of earnings between our U.S. operations and foreign subsidiaries, as our taxable income stems mostly from our operations located in China, which has a higher income tax rate than the U.S. In addition, during the first quarters of fiscal 2025 and 2024, we incurred pre-tax losses associated with our U.S. operations, for which an income tax benefit was not recorded due to the full valuation allowance applied against our U.S. net deferred income tax assets. The income tax charge associated with the full valuation allowance applied against our U.S. net deferred income tax assets was greater during the first quarter of fiscal 2025 compared with the first quarter of fiscal 2024, as our $(7.0) million U.S. pre-tax loss incurred during the first
I-39
quarter of fiscal 2025 was significantly greater than the $(3.3) million U.S. pre-tax loss incurred during the first quarter of fiscal 2024.
During the first quarter of fiscal 2025, we incurred a greater consolidated pre-tax loss totaling $(7.0) million, compared with $(2.6) million during the first quarter of fiscal 2024. As a result, the principal differences between income tax expense at the U.S. federal income tax rate and the effective income tax rate reflected in the consolidated financial statements were more pronounced during the first quarter of fiscal 2024, as compared with the first quarter of fiscal 2025.
U.S. Valuation Allowance
We evaluate the realizability of our U.S. net deferred income tax assets to determine if a valuation allowance is required. We assess whether a valuation allowance should be established based on the consideration of all available evidence using a “more-likely-than-not” standard, with significant weight being given to evidence that can be objectively verified. Since the company operates in multiple jurisdictions, we assess the need for a valuation allowance on a jurisdiction-by-jurisdiction basis, considering the effects of local tax law.
As of July 28, 2024, we evaluated the realizability of our U.S. net deferred income tax assets to determine if a full valuation allowance was required. Based on our assessment, we determined we still have a recent history of significant cumulative U.S. pre-tax losses, in that we experienced U.S. pre-tax losses during each of the last three fiscal years from 2022 through 2024, and we are currently expecting significant U.S. pre-tax losses to continue during fiscal 2025. As a result of the significant weight of this negative evidence, we believe it is more likely than not that our U.S. deferred income tax assets will not be fully realizable, and therefore we provided for a full valuation allowance against our U.S. net deferred income tax assets.
Based on our assessments as of July 28, 2024, July 30, 2023, and April 28, 2024, valuation allowances against our net deferred income tax assets pertain to the following:
(dollars in thousands) |
|
July 28, 2024 |
|
|
July 30, 2023 |
|
|
April 28, 2024 |
|
|||
U.S. federal and state net deferred income tax assets |
|
$ |
21,326 |
|
|
$ |
17,246 |
|
|
$ |
19,674 |
|
U.S. capital loss carryforward |
|
|
2,330 |
|
|
|
2,330 |
|
|
|
2,330 |
|
|
|
$ |
23,656 |
|
|
$ |
19,576 |
|
|
$ |
22,004 |
|
Undistributed Earnings
Refer to Note 14 of the consolidated financial statements for disclosures regarding our assessments of our recorded deferred income tax liability balances associated with undistributed earnings from our foreign subsidiaries as of July 28, 2024, July 30, 2023, and April 30, 2023, respectively.
Uncertain Income Tax Positions
Refer to Note 14 of the consolidated financial statements for disclosures regarding our assessments of our uncertain income tax positions as of July 28, 2024, July 30, 2023, and April 28, 2024, respectively.
Income Taxes Paid
The following table sets forth taxes paid by jurisdiction for the three months ending July 28, 2024, and July 30, 2023, respectively:
|
|
Three Months |
|
|
Three Months |
|
||
|
|
Ended |
|
|
Ended |
|
||
|
|
July 28, |
|
|
July 30, |
|
||
(dollars in thousands) |
|
2024 |
|
|
2023 |
|
||
China Income Taxes, Net of Refunds |
|
|
561 |
|
|
|
915 |
|
Canada - Income Taxes, Net of Refunds |
|
|
— |
|
|
|
197 |
|
|
|
$ |
561 |
|
|
$ |
1,112 |
|
Future Liquidity
Based on the restructuring plan approved by our board of directors on April 29, 2024, the timing and success of the closure of our Canadian operation, along with the sale of associated real estate (the timing and amount of which sales price is currently
I-40
undetermined), could have a significant effect on (i) the amount and timing of when and if fiscal 2024 income tax payments will be required; (ii) the amount and timing of withholding tax payments to the Canadian government associated with the repatriation of earnings and profits to the U.S. parent; and (iii) the respective tax rates that will be applied on the sale of real estate and equipment. Accordingly, we believe we cannot provide a reasonable estimate of our fiscal 2025 income tax payments associated with our Canadian operation at this time.
Currently, we are projecting annual cash income tax payments of approximately $2.0 million associated with our operations located in China. This estimate is management's current projection only and can be affected by actual earnings versus annual projections, changes in the foreign exchange rates in relation to the U.S. dollar, and the timing of when we will repatriate earnings and profits from China to our U.S. parent.
Currently, we do not expect to incur any income taxes in the U.S. on a cash basis during fiscal 2025 due to (i) the accelerated expensing of U.S. capital expenditures and our existing U.S. federal net operating loss carryforwards totaling $69.6 million as of April 28, 2024. As of July 28, 2024, we will be required to pay annual U.S. federal transition tax payments, in accordance with the 2017 Tax Cuts and Jobs Act, as follows: FY 2025 - $665,000; and FY 2026 - $831,000. The annual U.S. federal transition tax payment of $665,000 was paid during the second quarter of fiscal 2025.
Liquidity and Capital Resources
Liquidity
Overall
Currently, our sources of liquidity include cash and cash equivalents (collectively, "cash"), cash flow from operations, and amounts available under our revolving credit lines. As of July 28, 2024, we believe our cash of $13.5 million and the current availability under our revolving credit lines totaling $19.2 million will be sufficient to fund our foreseeable business needs, capital expenditures, commitments, and contractual obligations. Refer to Note 10 of the consolidated financial statements for further information regarding our revolving credit lines.
As of July 28, 2024, our cash totaled $13.5 million, an increase of $3.5 million compared with cash of $10.0 million as of April 28, 2024. This increase was mostly due $4.0 million in cash proceeds from borrowings on our line of credit associated with our operations located in China, partially offset by capital expenditures totaling $501,000.
Our net cash used in operating activities was $206,000 during the first quarter of fiscal 2025, a decrease of $4.2 million compared with net cash used in operating activities of $4.4 million during the first quarter of fiscal 2024. This trend mostly reflects (i) a decrease in accounts payable and accrued expenses during the first quarter of fiscal 2024 due to a decline in net sales for the first quarter of fiscal 2024 as compared with the first quarter of fiscal 2023, which decline did not recur during the first quarter of fiscal 2025 as compared with the first quarter of fiscal 2024; (ii) a decrease in inventory due to improved inventory management for both the mattress fabrics and upholstery fabrics segments and due to the gradual wind down of operations at the company's manufacturing facility in Quebec, Canada, as described above in the section titled “—Segment Analysis — Mattress Fabrics Segment — Restructuring Activities” of this Item 2 – MANAGEMENT’S DISCUSSION AND ANALYSIS OF FINANCIAL CONDITION; and (iii) a decrease in accounts receivable during the first quarter of fiscal 2024 due to a decline in net sales during the first quarter of fiscal 2024 as compared with the first quarter of fiscal 2023, which decline did not recur during the first quarter of fiscal 2025 as compared with the first quarter of fiscal 2024.
As of July 28, 2024, we had outstanding borrowings totaling $4.0 million under a line of credit agreement associated with our operations located in China. Refer to Note 10 of the consolidated financial statements for further information regarding our revolving this line of credit.
The income taxes we pay also affect our liquidity. See the above section titled “Income Taxes Paid” of this Item 2 – MANAGEMENT’S DISCUSSION AND ANALYSIS OF FINANCIAL CONDITION for further detail.
Our cash balance may be adversely affected by factors beyond our control, such as (i) recent customer demand trends affecting net sales, (ii) supply chain disruptions, (iii) higher interest rates and inflation, (iv) world events (including wars in Ukraine and Middle East), and (v) the continuing uncertainty associated with COVID-19. These factors could cause delays in receipt of payment on accounts receivable and could increase cash disbursements due to rising prices.
I-41
By Geographic Area
A summary of our cash by geographic area follows:
|
|
July 28, |
|
|
July 30, |
|
|
April 28, |
|
|||
(dollars in thousands) |
|
2024 |
|
|
2023 |
|
|
2024 |
|
|||
United States |
|
$ |
2,472 |
|
|
$ |
6,899 |
|
|
$ |
2,912 |
|
China |
|
|
10,462 |
|
|
|
8,902 |
|
|
|
6,554 |
|
Canada |
|
|
326 |
|
|
|
828 |
|
|
|
371 |
|
Haiti |
|
|
141 |
|
|
|
174 |
|
|
|
86 |
|
Vietnam |
|
|
62 |
|
|
|
— |
|
|
|
81 |
|
Cayman Islands |
|
|
9 |
|
|
|
9 |
|
|
|
8 |
|
|
|
$ |
13,472 |
|
|
$ |
16,812 |
|
|
$ |
10,012 |
|
|
|
|
|
|
|
|
|
|
|
|||
Common Stock Repurchase Program
In March 2020, our board of directors approved an authorization for us to acquire up to $5.0 million of our common stock. Under the common stock repurchase program, shares may be purchased from time to time in open market transactions, block trades, through plans established under the Securities Exchange Act Rule 10b5-1, or otherwise. The number of shares purchased and the timing of such purchases are based on working capital requirements, market and general business conditions, and other factors, including alternative investment opportunities.
We did not repurchase any shares of common stock during the three-month periods ending July 28, 2024, and July 30, 2023, respectively.
As of July 28, 2024, $3.2 million is available for additional repurchases of our common stock.
Dividends
On June 29, 2022, our board of directors announced the decision to suspend the company’s quarterly cash dividend. We believed that preserving capital and managing our liquidity were in the company’s best interest to support future growth and the long-term interests of our shareholders. Accordingly, we did not make any dividend payments during the first quarter of fiscal 2025, fiscal 2024, and fiscal 2023.
Working Capital
Operating Working Capital
Operating working capital (the total of accounts receivable and inventories, less accounts payable-trade, less accounts payable-capital expenditures, and less deferred revenue) was $35.1 million as of July 28, 2024, compared with $38.7 million as of July 30, 2023, and $38.5 million as of April 28, 2024. Operating working capital turnover was 5.9 during the first quarter of fiscal 2025, compared with 5.0 during the first quarter of fiscal 2024 and 5.8 during the fourth quarter of fiscal 2024.
Accounts Receivable
Accounts receivable was $21.6 million as of July 28, 2024, a decrease of $1.0 million, or 4.5%, compared with $22.6 million as of July 30, 2023. This decrease was due to faster cash collections from significant customers in both our mattress fabrics and upholstery fabrics segments who utilized more cash discounts during the first quarter of fiscal 2025, as compared with the first quarter of fiscal 2024. As a result, days’ sales outstanding decreased to 32 days for the first quarter of fiscal 2025, compared with 35 days for the first quarter of fiscal 2024.
Accounts receivable was $21.6 million as of July 28, 2024,and remained flat as compared with $21.1 million as of April 28, 2024. This reflects an increase in net sales during the first quarter of fiscal 2025, as compared with the fourth quarter of fiscal 2024. Net sales for the first quarter of fiscal 2025 were $56.5 million, an increase of $7.0 million, or 14.2%, compared with net sales of $49.5 million for the fourth quarter of fiscal 2024. However, this increase was offset by faster cash collections from significant customers in both our mattress fabrics and upholstery fabrics segments who utilized more cash discounts during the first quarter of fiscal 2025, as compared with the fourth quarter of fiscal 2024. As a result, days’ sales outstanding decreased to 32 days for the first quarter of fiscal 2025, compared with 36 days for the fourth quarter of fiscal 2024.
I-42
Inventory
Inventory was $41.7 million as of July 28, 2024, a decrease of $2.1 million, or 4.9%, compared with $43.8 million as of July 30, 2023. This decrease in inventory mostly pertains to our upholstery fabrics segment and reflects management's ability to maintain an appropriate level of inventory, taking into account current and expected future demand trends and any changes in our global supply chain.
Inventory was $41.7 million as of July 28, 2024, a decrease of $3.2 million, or 7.1%, compared with $44.8 million as of April 28, 2024. This decrease in inventory primarily relates to improved inventory management for both the mattress fabrics and upholstery fabrics segments during the first quarter of fiscal 2025, as compared with the fourth quarter of fiscal 2024, taking into account current and expected future demand trends.
Inventory turns were 4.8 for the first quarter of fiscal 2025, as compared with 4.5 for the first quarter of fiscal 2024 and 3.9 for the fourth quarter of fiscal 2024.
Accounts Payable - Trade
Accounts payable was $26.5 million, $26.5 million, and $25.6 million as of July 28, 2024, July 30, 2023, and April 28, 2024, respectively. These static levels of accounts payable reflect a consistent level of inventory of $41.7 million, $43.8 million, and $44.8 million as of July 28, 2024, July 30, 2023, and April 28, 2024, respectively.
Financing Arrangements
Currently, we have revolving credit agreements with banks for our U.S parent company and our operations located in China. As of July 28, 2024, we had outstanding borrowings totaling $4.0 million under a line of credit agreement associated with our operations located in China. Our loan agreements require, among other things, that we maintain compliance with certain financial covenants. As of July 28, 2024, we were in compliance with these financial covenants.
Refer to Note 10 of the consolidated financial statements for further disclosure regarding our revolving credit agreements.
Capital Expenditures and Depreciation
Overall
Capital expenditures on a cash basis during the first quarter of fiscal 2025 totaled $501,000, compared with $513,000 during the first quarter of fiscal 2024. This level of capital spending reflect the current unfavorable macro-economic conditions within the home furnishings and bedding industries.
Depreciation expense was $2.5 million during the first quarter of fiscal 2025, compared with $1.6 million for the same period a year ago. Depreciation expense mostly related to our mattress fabrics segment for both periods. In addition, during the three-month period ending July 28, 2024, depreciation expense for the mattress fabrics segment included $875,000 in additional depreciation expense related to the shortening of useful lives of equipment associated with our manufacturing facility located in Quebec, Canada. This $875,000 of additional depreciation expense was classified as restructuring expense in the Consolidated Statement of Net Loss for the three-month period ending July 28, 2024.
For the remainder of fiscal 2025, our capital spending will be centered on our mattress fabrics segment, with a strategic focus on capital projects that will increase efficiencies and improve the quality of our products. Funding for capital expenditures is expected to be from cash provided by operating activities.
Accounts Payable – Capital Expenditures
As of July 28, 2024, we had amounts due regarding capital expenditures totaling $56,000 that pertained to outstanding vendor invoices, none of which were financed. The total amount outstanding of $56,000 is required to be paid based on normal credit terms.
Purchase Commitments – Capital Expenditures
As of July 28, 2024, we had open purchase commitments to acquire equipment for our mattress fabrics segment totaling $275,000.
I-43
Critical Accounting Policies and Recent Accounting Developments
As of July 28, 2024, there were no changes in our significant accounting policies or the application of those policies from those reported in our annual report on Form 10-K for the year ended April 28, 2024.
Refer to Note 2 of the consolidated financial statements for recently adopted and issued accounting pronouncements, if any, since the filing of our Form 10-K for the year ended April 28, 2024.
Contractual Obligations
There were no significant or new contractual obligations since those reported in our annual report on Form 10-K for the year ended April 28, 2024.
Inflation
Any significant increase in our raw material costs, utility/energy costs, and general economic inflation could have a material adverse impact on the company, because competitive conditions have limited our ability to pass significant operating cost increases on to customers.
During fiscal 2024 and continuing through the first quarter of fiscal 2025, raw material costs started to decline due to slowing global demand; however, the cost of labor remained challenging during fiscal 2024 and continuing through the first quarter of fiscal 2025.
Inflationary pressures also affected consumer spending during fiscal 2024 and continued through the first quarter of fiscal 2025, causing a slowdown in business in both the mattress industry and the residential home furnishings industry. This slowdown has caused reduced demand from producers of home furnishings for our mattress fabrics and residential upholstery fabrics products during fiscal 2024 and in the first quarter of fiscal 2025.
We are unable to predict how long these trends will last, or to what extent inflationary pressures may affect the economic and purchasing cycle for home furnishing products (and therefore affect demand for our products) over the short and long term.
I-44
ITEM 3. QUANTITATIVE AND QUALITATIVE DISCLOSURES ABOUT MARKET RISK
Interest Rates
We are exposed to market risk from changes in interest rates on our revolving credit agreements.
Effective January 19, 2023, we entered into a second amended and restated U.S. revolving credit agreement (the "Amended Agreement") to establish an asset-based revolving credit facility that required interest to be charged at a rate calculated using an applicable margin over Federal Reserve Bank of New York's secured overnight fund rate (SOFR), as defined in the Amended Agreement. The interest rate under the Amended Agreement as of July 28, 2024, was 6.84%. As of July 28, 2024, there were no outstanding borrowings under the Amended Agreement.
Effective March 20, 2024, we entered into an unsecured credit agreement with a financial institution in China denominated in RMB that requires interest to be charged at a rate based on the Loan Prime Rate ("LPR") in China minus 50 basis points (2.85% as of July 28, 2024). There were outstanding borrowings under this agreement totaling $4.0 million as of July 28, 2024.
Our previously existing revolving credit agreement with another financial institution in China bears interest at a rate determined by the Chinese government at the time of borrowing, and is not directly determined by a published interest rate benchmark. There were no borrowings outstanding under this agreement as of July 28, 2024.
Foreign Currency
We are exposed to market risk from changes in the value of foreign currencies for our subsidiaries domiciled in Canada, China, and Vietnam. We try to maintain a natural hedge by keeping a balance of our assets and liabilities denominated in the local currency of our subsidiaries domiciled in Canada, China, and Vietnam. However, there is no assurance that we will be able to continually maintain this natural hedge. Our foreign subsidiaries use the U.S. dollar as their functional currency. A substantial portion of the company’s imports purchased outside the U.S. are denominated in U.S. dollars. A 10% change in the above exchange rates as of July 28, 2024, would not have materially affected our results of operations or financial position.
ITEM 4. CONTROLS AND PROCEDURES
As of July 28, 2024, we conducted an evaluation of the effectiveness of our disclosure controls and procedures, as defined in Rules 13a-15(e) and 15d-15(e) under the Securities Exchange Act of 1934, as amended (the “Exchange Act”). This evaluation was conducted under the supervision and with the participation of our management, including our Chief Executive Officer and Chief Financial Officer. Based upon that evaluation, our Chief Executive Officer and Chief Financial Officer concluded that these disclosure controls and procedures were effective as of such date, in all material respects, to ensure that information required to be disclosed in the reports filed by us and submitted under the Exchange Act, is recorded, processed, summarized, and reported as and when required, and that these disclosure controls and procedures were effective as of such date to ensure that information required to be disclosed in reports filed by us under the Exchange Act is accumulated and communicated to management, including our Chief Executive Officer and Chief Financial Officer, in a manner to allow timely decisions regarding the required disclosure.
During the quarter ended July 28, 2024, there were no changes in our internal control over financial reporting that have materially affected, or are reasonably likely to materially affect, our internal control over financial reporting.
I-45
Part II – Other Information
Item 1. Legal Proceedings
There have not been any material changes to our legal proceedings during the three months ended July 28, 2024. Our legal proceedings are disclosed in the company’s annual report on Form 10-K filed with the Securities and Exchange Commission on July 12, 2024, for the fiscal year ended April 28, 2024.
Item 1A. Risk Factors
There have not been any material changes to our risk factors during the three months ended July 28, 2024. Our risk factors are disclosed in Item 1A “Risk Factors” of the company’s annual report on Form 10-K filed with the Securities and Exchange Commission on July 12, 2024, for the fiscal year ended April 28, 2024.
Item 2. Unregistered Sales of Equity Securities and Use of Proceeds
ISSUER PURCHASES OF EQUITY SECURITIES
|
|
|
|
|
|
|
|
(c) |
|
|
(d) |
|
||||
|
|
|
|
|
|
|
|
Total Number of |
|
|
Approximate |
|
||||
|
|
(a) |
|
|
|
|
|
Shares Purchased |
|
|
Dollar Value of |
|
||||
|
|
Total |
|
|
(b) |
|
|
as Part of |
|
|
Shares that May |
|
||||
|
|
Number |
|
|
Average |
|
|
Publicly |
|
|
Yet Be Purchased |
|
||||
|
|
of Shares |
|
|
Price Paid |
|
|
Announced Plans |
|
|
Under the Plans or |
|
||||
Period |
|
Purchased |
|
|
per Share |
|
|
or Programs |
|
|
Programs (1) |
|
||||
April 29, 2024 to June 2, 2024 |
|
|
— |
|
|
|
— |
|
|
|
— |
|
|
$ |
3,248,094 |
|
June 3, 2024 to June 30, 2024 |
|
|
— |
|
|
|
— |
|
|
|
— |
|
|
$ |
3,248,094 |
|
July 1, 2024 to July 28, 2024 |
|
|
— |
|
|
|
— |
|
|
|
— |
|
|
$ |
3,248,094 |
|
Total |
|
|
— |
|
|
|
— |
|
|
|
— |
|
|
$ |
3,248,094 |
|
Item 5. Other Information
During the three months ended July 28, 2024, none of the company's directors or officers (as defined in Rule 16a-1(f) of the Securities Exchange Act of 1934) adopted or terminated a "Rule 10b5-1 trading arrangement" or a "non-Rule 10b5-1 trading arrangement" (as such terms are defined in Item 408 of Regulation S-K).
II-1
Item 6. Exhibits
The following exhibits are submitted as part of this report.
31.1 Certification of Chief Executive Officer Pursuant to Rule 13a-14(a)/15d-14(a).
31.2 Certification of Chief Financial Officer Pursuant to Rule 13a-14(a)/15d-14(a).
32.1 Certification of Chief Executive Officer Pursuant to 18 U.S.C. Section 1350.
32.2 Certification of Chief Financial Officer Pursuant to 18 U.S.C. Section 1350.
as Exhibit 10.1 to the company's Form 8-K dated June 17, 2024, and incorporated herein by reference.
August 14, 2024, and incorporated herein by reference.
101.INS Inline XBRL Instance Document
101.SCH Inline XBRL Taxonomy Extension Schema Document
101.CAL Inline XBRL Taxonomy Extension Calculation Linkbase Document
101.LAB Inline XBRL Taxonomy Extension Label Linkbase Document
101.PRE Inline XBRL Taxonomy Extension Presentation Linkbase Document
101.DEF Inline XBRL Taxonomy Extension Definition Linkbase Document
104 Cover Page Interactive Data File (formatted as Inline XBRL with applicable taxonomy extension information contained in Exhibits 101).
II-2
SIGNATURES
Pursuant to the requirements of the Securities Exchange Act of 1934, the registrant has duly caused this report to be signed on its behalf by the undersigned thereunto duly authorized.
|
|
|
|
CULP, INC. (Registrant) |
|
|
|
|
|
Date: September 6, 2024 |
|
By: |
|
/s/ Kenneth R. Bowling |
|
|
|
|
Kenneth R. Bowling |
|
|
|
|
Executive Vice President and Chief Financial Officer |
|
|
|
|
(Authorized to sign on behalf of the registrant and also signing as principal financial officer and principal accounting officer) |
|
|
|
|
|
|
|
|
|
|
II-3
Exhibit 31.1
CERTIFICATIONS
I, Robert G. Culp, IV, certify that:
1. I have reviewed this Form 10-Q of Culp, Inc.;
2. Based on my knowledge, this report does not contain any untrue statement of a material fact or omit to state a material fact necessary to make the statements made, in light of the circumstances under which such statements were made, not misleading with respect to the period covered by this report;
3. Based on my knowledge, the financial statements, and other financial information included in this report, fairly present in all material respects the financial condition, results of operations and cash flows of the registrant as of, and for, the periods presented in this report;
4. The registrant’s other certifying officer(s) and I are responsible for establishing and maintaining disclosure controls and procedures (as defined in Exchange Act Rules 13a-15(e) and 15d-15(e)) and internal control over financial reporting (as defined in Exchange Act Rules 13a-15(f) and 15d-15(f)) for the registrant and have:
(a) Designed such disclosure controls and procedures, or caused such disclosure controls and procedures to be designed under our supervision, to ensure that material information relating to the registrant, including its consolidated subsidiaries, is made known to us by others within those entities, particularly during the period in which this report is being prepared;
(b) Designed such internal control over financial reporting, or caused such internal control over financial reporting to be designed under our supervision, to provide reasonable assurance regarding the reliability of financial reporting and the preparation of financial statements for external purposes in accordance with generally accepted accounting principles;
(c) Evaluated the effectiveness of the registrant’s disclosure controls and procedures and presented in this report our conclusions about the effectiveness of the disclosure controls and procedures, as of the end of the period covered by this report based on such evaluation; and
(d) Disclosed in this report any change in the registrant’s internal control over financial reporting that occurred during the registrant’s most recent fiscal quarter (the registrant’s fourth fiscal quarter in the case of an annual report) that has materially affected, or is reasonably likely to materially affect, the registrant’s internal control over financial reporting; and
5. The registrant’s other certifying officer(s) and I have disclosed, based on our most recent evaluation of internal control over financial reporting, to the registrant’s auditors and the audit committee of the registrant’s board of directors (or persons performing the equivalent functions):
(a) All significant deficiencies and material weaknesses in the design or operation of internal control over financial reporting which are reasonably likely to adversely affect the registrant’s ability to record, process, summarize and report financial information; and
(b) Any fraud, whether or not material, that involves management or other employees who have a significant role in the registrant’s internal control over financial reporting.
|
|
/s/ Robert G. Culp, IV |
|
|
Robert G. Culp, IV |
|
|
President and Chief Executive Officer |
|
|
(Principal Executive Officer) |
Date: September 6, 2024
Exhibit 31.2
CERTIFICATIONS
I, Kenneth R. Bowling, certify that:
1. I have reviewed this Form 10-Q of Culp, Inc.;
2. Based on my knowledge, this report does not contain any untrue statement of a material fact or omit to state a material fact necessary to make the statements made, in light of the circumstances under which such statements were made, not misleading with respect to the period covered by this report;
3. Based on my knowledge, the financial statements, and other financial information included in this report, fairly present in all material respects the financial condition, results of operations and cash flows of the registrant as of, and for, the periods presented in this report;
4. The registrant’s other certifying officer(s) and I are responsible for establishing and maintaining disclosure controls and procedures (as defined in Exchange Act Rules 13a-15(e) and 15d-15(e)) and internal control over financial reporting (as defined in Exchange Act Rules 13a-15(f) and 15d-15(f)) for the registrant and have:
(a) Designed such disclosure controls and procedures, or caused such disclosure controls and procedures to be designed under our supervision, to ensure that material information relating to the registrant, including its consolidated subsidiaries, is made known to us by others within those entities, particularly during the period in which this report is being prepared;
(b) Designed such internal control over financial reporting, or caused such internal control over financial reporting to be designed under our supervision, to provide reasonable assurance regarding the reliability of financial reporting and the preparation of financial statements for external purposes in accordance with generally accepted accounting principles;
(c) Evaluated the effectiveness of the registrant’s disclosure controls and procedures and presented in this report our conclusions about the effectiveness of the disclosure controls and procedures, as of the end of the period covered by this report based on such evaluation; and
(d) Disclosed in this report any change in the registrant’s internal control over financial reporting that occurred during the registrant’s most recent fiscal quarter (the registrant’s fourth fiscal quarter in the case of an annual report) that has materially affected, or is reasonably likely to materially affect, the registrant’s internal control over financial reporting; and
5. The registrant’s other certifying officer(s) and I have disclosed, based on our most recent evaluation of internal control over financial reporting, to the registrant’s auditors and the audit committee of the registrant’s board of directors (or persons performing the equivalent functions):
(a) All significant deficiencies and material weaknesses in the design or operation of internal control over financial reporting which are reasonably likely to adversely affect the registrant’s ability to record, process, summarize and report financial information; and
(b) Any fraud, whether or not material, that involves management or other employees who have a significant role in the registrant’s internal control over financial reporting.
|
|
/s/ Kenneth R. Bowling |
|
|
Kenneth R. Bowling |
|
|
Executive Vice President and Chief Financial Officer |
|
|
(Principal Financial Officer and Principal Accounting Officer) |
Date: September 6, 2024
Exhibit 32.1
Certification Pursuant to
18 U.S.C. Section 1350,
as Adopted Pursuant to
Section 906 of the Sarbanes-Oxley Act of 2002
In connection with the Quarterly Report of Culp, Inc. (the “Company”) on Form 10-Q for the period ended July 28, 2024, as filed with the Securities and Exchange Commission on the date hereof (the “Report”), I, Robert G. Culp, IV, certify, pursuant to 18 U.S.C. Section 1350, as adopted pursuant to Section 906 of the Sarbanes-Oxley Act of 2002, that, to my knowledge:
(1) The Report fully complies with the requirements of Section 13(a) or 15(d) of the Securities Exchange Act of 1934; and
(2) The information contained in the Report fairly presents, in all material respects, the financial condition and result of operations of the Company.
/s/ Robert G. Culp, IV |
Robert G. Culp, IV |
President and Chief Executive Officer |
September 6, 2024
A signed original of this written statement required by Section 906, or other document authenticating, acknowledging, or otherwise adopting the signature that appears in typed form within the electronic version of this written statement required by Section 906 has been provided to Culp, Inc. and will be retained by Culp, Inc. and furnished to the Securities and Exchange Commission or its staff upon request.
Exhibit 32.2
Certification Pursuant to
18 U.S.C. Section 1350,
as Adopted Pursuant to
Section 906 of the Sarbanes-Oxley Act of 2002
In connection with the Quarterly Report of Culp, Inc. (the “Company”) on Form 10-Q for the period ended July 24, 2024, as filed with the Securities and Exchange Commission on the date hereof (the “Report”), I, Kenneth R. Bowling, certify, pursuant to 18 U.S.C. Section 1350, as adopted pursuant to Section 906 of the Sarbanes-Oxley Act of 2002, that, to my knowledge:
(1) The Report fully complies with the requirements of Section 13(a) or 15(d) of the Securities Exchange Act of 1934; and
(2) The information contained in the Report fairly presents, in all material respects, the financial condition and result of operations of the Company.
/s/ Kenneth R. Bowling |
Kenneth R. Bowling |
Executive Vice President and Chief Financial Officer |
September 6, 2024
A signed original of this written statement required by Section 906, or other document authenticating, acknowledging, or otherwise adopting the signature that appears in typed form within the electronic version of this written statement required by Section 906 has been provided to Culp, Inc. and will be retained by Culp, Inc. and furnished to the Securities and Exchange Commission or its staff upon request.